1973 Gran Torion Sport 351 on 2040-cars

Auto blog

A cool boost to turbocharger performance

Since the advent of the forced-induction engine, we have been looking for ways to get every drop of performance we can. There are many approaches to getting additional power using better intercooling, water injection, or even adding nitrous oxide. One take on a short instant burst of power is being researched by Mahle and involves providing supercooled air to an engine, which allows it to burn a leaner fuel mixture and produce more power. The supercooling idea is not new and was examined by Ford in 1993 on the Mustang Mach III concept car, then brought up again in 2003 with the SVT F-150 Lightning concept. Ford called its system the SuperCooler; it was designed to work with any turbocharged or supercharged engine equipped with a water-to-air intercooler. The system on the Lightning concept used a small tank of antifreeze that was hooked up to the truck air conditioning compressor. The air conditioning compressor cooled the antifreeze down to about 30 degrees. The other side of the tank was hooked up to the air-to-water intercooler, which usually had a temperature over 100 degrees. Once the antifreeze was circulated from the tank into the intercooler, it would lower the intercooler temperature and provide for a cooler, denser air charge into the engine; the result was around 50 extra horsepower for a burst of about 30 seconds to a minute, depending on the size of the tank. The system for the Lightning was to be offered as a $750 option and would have been targeted towards drag racers and the like, as it could be used for a run down the drag strip and then re-cooled by the time the truck was back in line. The system was fairly non-intrusive – it only weighed about 25 pounds and did not require a new compressor or intercooler. But as with many concepts, it was ultimately scrapped. The technology was always stuck in the back of my mind, but with larger and more powerful engines being produced it could not find its place. With the advent of new fuel economy standards, we have seen small-displacement turbocharged engines pop up and they seem like the perfect candidate for this type of technology. Ford's EcoBoost 1.0-liter three-cylinder turbocharged engine, as used in the Fiesta and Focus, is one such candidate for this technology. It would add a negligent amount of weight but could provide a boost of 10 to 20 horsepower when needed, like merging onto the highway or catching up to traffic.

Recharge Wrap-up: Grimsel electric car breaks acceleration world record, electric Ford Raptor ATV debuts

An all-electric version of the Ford F-150 SVT Raptor is now available... as an ATV. Made by Caddyshack Golf Cars, it features officially licensed Ford badging borrowed from the super-macho pickup. It has a lifted chassis with leaf springs in the front and rear, hydraulic shocks and off-road tires. Powered by a 48-volt motor, it can do 0-25 mph in 2.9 seconds. Range is an estimated 30 miles - plenty to get you through 18 of the most rugged holes of golf you've ever played. Caddyshack also offers other miniature electric Fords, including a Shelby GT500, Shelby Cobra and 50th Anniversary Mustang. Read more at Green Car Reports. Lexus takes a crack at the BMW i3 in a new video from Funny or Die. In the decidedly anti-EV film, a group of guys drives to Las Vegas for a "dad-chelor party" in a Lexus CT 200h and a BMW i3. The Lexus hybrid makes it to Sin City without any problems, while the BMW's occupants need to make several lengthy stops to charge along the way, missing much of the fun. The video lampoons the inherent range limitations of the EV (the BMW group ends up driving slowly through the desert with no AC or radio to save energy), all in a well produced, if somewhat misguided, short comedy film. Perhaps they should have considered the i3 with a range extender? See the video below, or read more at Green Car Reports. Students from ETH Zurich and Lucerne University have set a new EV acceleration world record. Their "Grimsel" racing car was able to zoom from 0-100 kph (0-62.137 mph) in just 1.785 seconds in less than 30 meters (98.425 feet), crushing the previous record of 2.134 seconds. Even more impressive is that the Grimsel was built by the students themselves, as part of the Formula Student team at the Academic Motorsports Club Zurich. The car weighs just 370 pounds and provides 200 horsepower and 1,202 pound feet of torque from the four hub motors. The Grimsel uses traction control to manage torque for maximum acceleration. See the record acceleration run in the videos below or read more at Gizmag, at Electric Autosport or in the press release from ETH Zurich below. 'grimsel' breaks world record The 'grimsel' electric racing car today broke the previous world record for acceleration in electric cars. The vehicle accelerated from 0 to 100 km/h in 1.785 seconds in under 30 metres. The new record was set by students from ETH Zurich and Lucerne University of Applied Sciences and Arts, who also designed and built the vehicle.

NHTSA investigating 500k Ford and Mercury cars for lighting failures

The Ford Crown Victoria and Mercury Grand Marquis might be long gone as new models in showrooms, but the National Highway Traffic Safety Administration might check them out yet again for a potential problem. At the urging of North Carolina Consumers Council, the agency may open another investigation into the front lighting control module on vehicles from the 2003-2005 model years, and NHTSA estimates the issue could affect 517,945 vehicles. If the module stops working, it can cause a complete failure of all forward lighting, including the headlights. NHTSA previously investigated the issue in 2008 and 2009 but found no need for a recall, according to Bloomberg. Ford also extended the warranty on the part to 15 years or 250,000 miles. To prompt this new request, the North Carolina Consumers Council received a letter from a woman experiencing the module's failure. Upon further investigation, the council found 604 complaints of this problem on NHTSA's website, including seven crashes. Furthermore, the group has alleged that dealers told customers that the parts to perform the replacement weren't available, despite the extended warranty. According to the government agency, "A defect petition has been opened to evaluate the issue and make a grant or deny decision." Ford spokesperson Kelli Felker tells Autoblog via email, "We will cooperate with NHTSA, as we always do." You can read the council's complete letter to the Feds in PDF format, here. INVESTIGATION Subject : Loss of headlamp/exterior lighting Date Investigation Opened: APR 01, 2015 Date Investigation Closed: Open NHTSA Action Number: DP15002 Component(s): EXTERIOR LIGHTING All Products Associated with this Investigation Vehicle Make Model Model Year(s) FORD CROWN VICTORIA 2003-2005 MERCURY GRAND MARQUIS 2003-2005 Details Manufacturer: Ford Motor Company SUMMARY: The Office of Defects Investigation (ODI) has received a petition from the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The petition letter is attached for review. The petitioner alleges a defect in the lighting control module that powers the headlights which can result in the loss of vehicle headlights and/or all exterior lighting while driving. ODI has previously investigated this issue under PE08-066 which was closed without a defect finding.