1965 Ford Thunderbird on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

Ford to build Explorer in Russia to meet demand [w/video]

The current Ford Explorer is sold in more than 64 countries, and this three-row vehicle continues to grow in popularity worldwide. To keep up with demand, Ford began producing the Explorer at Ford Sollers Elabuga Assembly Plant in Tatarstan, Russia, a joint venture facility. This partnership will build Russian-market Explorers only, and production of export vehicles not destined for Russian buyers will continue to be built at Ford's assembly plant in Chicago.
Before this plant went online, Ford would ship Explorers to Russia (and other regions around the world) as partially assembled knock-down units where final assembly would eventually take place. While there is no indication as to how many Explorers Ford Sollers will build for Russia, Ford did add that exports of the SUV were up 65 percent last year (from 2011) accounting for more than 24,000 units.
Scroll down for a press release about the Russian Explorer as well as a video (bad music and all) showing the SUV being produced in Tatarstan.

Ford F-150, Mustang, Explorer, Bronco and Lincoln Aviator recalled for rollaway fears

Ford is recalling certain F-150, Mustang, Explorer, Bronco, and Lincoln Aviator models from the 2022 and 2023 model years equipped with automatic transmissions. According to documents posted by the National Highway Traffic Safety Administration, Ford's 10R80 transmission may contain a loose bolt — literally an extra bolt loose inside the transmission, not a bolt that isn't tightened — that could prevent the transmission from engaging in Park. This could happen even if the gear shifter position indicates that the vehicle has been shifted to "Park." As Ford's recall acknowledgement says, "The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury." Dealers will replace the transmissions of vehicles affected by this defect. Note a similar-sounding recall was announced in 2022, but it was for entirely different models with entirely different transmissions. A relatively small number of units — 944 to be exact, or 4% of production — are thought to be affected by this issue, but they weren't built in successive order, meaning their VINs need to be verified by Ford. Customers are advised to contact Ford customer service at 1-866-436-7332 and reference Ford's internal recall number 23S06. Because some vehicles affected by this recall could be on dealer lots, Ford sent a note to its network of dealerships advising them not to sell or demonstrate the models included in this recall, potentially until the second quarter of 2023 when Ford expects "that parts ordering information and repair instructions will be available to support this safety recall." Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. 2023 Ford Bronco Heritage Edition walkaround