Ford 45 Truck on 2040-cars

Auto blog

Fewest vehicles ever found eligible for Most American survey

Once again, the most American car on the market is from an American brand. The Ford F-150 retained its number one spot in Cars.com's annual survey of the most American vehicles, trumping the Toyota Camry, which remains at number two.
Ford taking the top spot is small consolation, though, as the Detroit Three aren't too well represented here. General Motors scored a win at number seven, with the Chevrolet Corvette, while Chrysler squeaked in at number ten, with the Dodge Viper. Outside of those three vehicles, Toyota and Honda dominate the top ten.
What's most remarkable, though, is that there were so few cars available for this year's list.

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

Ford announces fix for 2021 Expedition and Lincoln Navigator fires

In the middle of May, Ford announced a recall of around 39,000 Ford Expeditions and Lincoln Navigators from the 2021 model year due to fires starting under the hoods of the SUVs. At the time, Ford had received 16 incident reports, 14 of them happening with rental vehicles. The automaker cautioned owners to park their vehicles outside and away from structures while engineers figured out what was happening and how to fix the problem. Since that May announcement, five more fires have been reported, four of them rental vehicles, and there's been one burn injury. The company announced it understands the problem and has a fix, at the same time widening the scope of potentially affected vehicles. Instead of recalling 39,013 units built between December 1, 2020, and April 30, 2021, the recall now includes 66,221 vehicles assembled from July 27, 2020, to Aug. 31, 2021. The suspected culprit is a circuit board provided by a supplier that changed manufacturing location during the pandemic. Ford's press release on the matter stated that "circuit boards produced at this facility are uniquely susceptible to a high-current short." The affected vehicles are fitted with either an 800-watt or 700-watt cooling fan system. About a third of the recalled population are fitted with the former, and should get a quick fix at the dealer. On these SUVs, techs will inspect the battery junction box. If they find evidence of melting, they'll replace the whole box. If not, they'll simply remove the engine fan ground wire that runs to the battery junction box; since this ground relay is redundant, the change doesn't alter operation of the fans.  Owners with the 700-watt system might need to wait until September for a fix. These vehicles need an auxiliary relay box with a wire jumper, but the parts aren't available now.   Ford's notifying all owners via the FordPass app, and will follow up with owners of the 700-watt cooling system once the parts are in stock. Until their vehicles are fixed, Ford says the SUVs are safe to drive but that they should still be parked outside and away from structures. The somewhat mixed messaging — 'Yes, your cars are safe to drive, but they could catch fire so don't park them near anything flammable' — encouraged a group of owners to file suit against Ford. Owners with questions can contact Ford customer service at 866-436-7332 and reference recall No. 22S36.