1967 Ford Mustang on 2040-cars

Auto blog

Ford celebrates 1 millionth Mustang built at Flat Rock

Yesterday, the Ford Mustang turned 49 years old, and Ford didn't miss the opportunity to celebrate the one millionth version of the Mustang rolling off the assembly line at the Flat Rock Assembly plant. Production of the Mustang at Flat Rock coincided with the fifth-generation design launching in 2004, and the one millionth car was the car shown above, a 2014 GT convertible painted in Ruby Red.
In total, Ford has sold more than 8.5 million Mustangs since the original car went on sale, but some of the key milestones over the car's nine years at Flat Rock include the Shelby GT-H, Bullitt, Boss 302 and, of course, the 662-horsepower Shelby GT500. Scroll down for a press release celebrating Flat Rock's milestone Mustang.

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

Lexus tops JD Power Vehicle Dependability Study again, Buick bests Toyota

It shouldn't surprise anyone, but Lexus has once again taken the top spot in JD Power's Vehicle Dependability Study. That'd be the Japanese luxury brand's fourth straight year at the top of table. The big news, though, is the rise of Buick. General Motor's near-premium brand beat out Toyota to take second place, with 110 problems per 100 vehicles compared to Toyota's 111 problems. Lexus owners only reported 89 problems per 100 vehicles. Besides Buick's three-position jump, Scion enjoyed a major improvement, jumping 13 positions from 2014. Ram and Mitsubishi made big gains, as well, moving up 11 and 10 positions, respectively. In terms of individual segments, GM and Toyota both excelled, taking home seven segment awards each. The study wasn't good news for all involved, though. A number of popular automakers finished below the industry average of 147 problems per 100 vehicles, including Subaru, (157PP100), Volkswagen (165PP100), Ford/Hyundai (188PP100 each) and Mini (193PP100). The biggest losers (by a tremendous margin, we might add) were Land Rover and Fiat, recording 258 and 273 problems per 100 vehicles. The next closest brand was Jeep, with 197PP100. While the Vehicle Dependability Study uses the same measurement system as the Initial Quality Survey, the two metrics analyze very different things. The VDS looks at problems experienced by original owners of model year 2012 vehicles over the past 12 months, while the oft-quoted IQS focuses on problems in the first 90 days of new-vehicle ownership. Like the IQS, though, the VDS has a rather broad definition of what a problem is. Because of that, a low score from JD Power is no guarantee of extreme unreliability, so much as just poor design. In this most recent study, the two most reported problems focused on Bluetooth connectivity and the voice-command systems. The former leaves plenty of room for user error due to poor design (particularly true of the Bluetooth systems on the low-scoring Fords, Volkswagens and Subarus), while the second is something JD Power has already confirmed as being universally terrible. That makes means that while these studies are important, they shouldn't be taken as gospel when it comes to automotive reliability. News Source: JD PowerImage Credit: Copyright 2015 Jeremy Korzeniewski / AOL Buick Fiat Ford GM Hyundai Jeep Land Rover Lexus MINI Mitsubishi RAM Scion Subaru Toyota Volkswagen Auto Repair Ownership study