1928 Hot Rod Rat Rod Ford Model A on 2040-cars

Auto blog

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.

Ford made three big mistakes in calculating MPG for 2013 C-Max Hybrid

It's been a rough time for the official fuel economy figures for the Ford C-Max Hybrid. When the car was released in 2012, Ford made a huge deal about how it would beat the Toyota Prius V, which was rated at 42 combined miles per gallon, 44 city and 40 highway. The Ford? 47 mpg across the board. How did Ford come to this place, where its Prius-beater turned into an also-ran? Well, after hearing customer complaints and issuing a software update in mid-2013, then discovering a real problem with the numbers last fall and then making a big announcement last week that the fuel economy ratings of six different 2013 and 2014 model year vehicles would need to be lowered, the C-Max Hybrid has ended up at 40 combined, 42 city and 37 highway. In other words, the Prius trumps it, as daily drivers of those two vehicles have known for a long time. The changes will not only affect the window sticker, but also the effect that the C-Max Hybrid (and the five other Ford vehicles that had their fuel economy figures lowered last week) have on Ford's compliance with greenhouse gas and CAFE rules for model year 2013 and 2014. How did Ford come to this place, where its Prius-beater turned into an also-ran? There are two technical answers to that question, which we've got below, as well as some context for how Ford's mistakes will play out in the bigger world of green vehicles. Let's start with Ford's second error, which is easy to do since we documented it in detail last year (the first, needing to do a software update, was also covered). The basic gist is that Ford used the general label rule (completely legally) to test the Fusion Hybrid and use those numbers to figure out how efficient the C-Max Hybrid is. That turned out to be a mistake, since the two vehicles are different enough that their numbers were not comparable, despite having the same engine, transmission and test weight, as the rules require. You can read more details here. Ford's Said Deep admitted that the TRLHP issue is completely separate from the general label error from last year. Now let's move on to last week's announcement. What's interesting is that the new recalculation of the MPG numbers – downward, of course – was caused by a completely separate issue, something called the Total Road Load Horsepower (TRLHP). Ford's Said Deep admitted to AutoblogGreen that the TRLHP issue had nothing to do with the general label error from last year.

Ford wins second consecutive International Van of the Year award with Transit Connect

The redesigned 2014 Ford Transit Connect isn't even on sale yet, but it's already making its presence felt around the world. At a commercial vehicle expo in Russia, the Transit Connect was named the International Van of the Year.
Ford's small work van edged out the new Mercedes-Benz Sprinter by just seven points to allow Ford to grab this honor for the second consecutive year, which it won last year with the Transit Custom. Not only does this make Ford the first to ever win the award in back-to-back years, but it's also the fifth time the automaker has won this award since 2003 (two with the Transit Connect, two with the fullsize Transit and once with the Transit Custom). Ford congratulates itself for the accomplishment in a press release posted below.