Auto blog

Ford offering factory-spec EcoBoost reflashes that don't void warranty*

Buy a supercharger or cold-air kit from Ford Racing and a Performance Calibration handset comes with it to reset the ECU for the upgrade. Now Ford Racing is offering the ProCal handset a la carte for $595, allowing you to reflash the ECU on your EcoBoost-equipped ride to extract more of its inherent capabilities without any additional upgrades. It gives you control of variables such as throttle response, idle speed and turbo wastegate control, among others. As for that warranty asterisk, the press release says enthusiasts can up the power "while maintaining the Ford-backed limited warranty." However Ford Motor Co. and Ford Racing are separate entities, and, best we can tell, when you reflash the ECU, your Ford warranty gets supplanted by the Ford Racing warranty. Say you bought a 2014 Ford, that means your five-year, 60,000-mile warranty becomes Ford Racing's three-year, 36,000-mile warranty, if we're reading the fine print correctly. If you have an older car and have driven more than 36,000 miles, then your warranty options are kaput, at least as far as a Ford in-house option. If have warranty concerns, you might also want to consider having a dealer perform the reflash, or at least ask about it. Once you've got past the small print, what about the numbers? At the moment Ford Racing offers tunes for the 2.0-liter EcoBoost in the Focus ST and the 1.6-liter EcoBoost in the Fiesta ST, and we're told there's a 90-pound-foot boost in torque at the crank after you've pressed the right buttons. Anecdotal evidence from a commenter at Road & Track says he went from 252 horsepower at the flywheel to 254 hp at the wheels, and 272 lb-ft at the flywheel to 354 lb-ft at the wheels, but we can't be sure that his adjustments were within Ford Racing specs. Your mileage, naturally, may vary. What about custom numbers for the 2.3-liter EcoBoost in the 2015 Ford Mustang? They aren't ready yet, but we're told we'll get something by the end of next year. Featured Gallery 2015 Ford Focus ST News Source: Ford, Ford Racing via Car and Driver Aftermarket Ford Technology ecoboost ford focus st ford fiesta st ford racing

Here's what the UAW will be angling for in next year's contract negotiations

The United Auto Workers union is about to enter a new round of negotiations with the Detroit Three automakers, and this time, the focus is on the end of the two-tier wage system. Introduced in 2007, the two-tier wage system was enacted to allow General Motors, Ford and Chrysler to categorize its hourly employees under two categories: Tier 1 for veteran employees with full rights and benefits, and Tier 2 for short-term or entry-level employees compensated under a different schedule. The idea was that the system would permit the automakers to invest more in their plants and hire new employees as part of their respective recovery plans without being saddled with all the costs associated with hiring full-time employees. Now that the automakers are (more or less) back on their proverbial feet, however, the UAW wants to see an end to the two-tier system, and will likely make that a center-point of its negotiations next year to replace the current arrangement that is scheduled to end in September 2015. Not all members of the UAW will necessarily be interested in ending the two-tier system, however. According to The Detroit News, some Tier 1 workers may be more interested in negotiating a raise in their hourly rate – something which they haven't received in almost a decade. Tier 2 workers, meanwhile, may be more motivated to keep the tiered system in place, as their arrangement includes provisions for profit-sharing payments that have seen the automakers pay out billions to so-called short-term employees in lump-sum payments. Reconciling the two competing demands from two categories of union members and presenting a united front in negotiations may prove the biggest challenge for the UAW's new president, Dennis Williams. And with the right to strike – something which was suspended during the last round of negotiations in 2011 – the union has a bigger bargaining chip in its pocket.

Even Ford executives had issues with MyFord Touch

MyFord Touch is one of the auto industry's more controversial features. The media broadly panned the infotainment system developed with Microsoft for its slow responses and reliance on voice commands to navigate its deep menus. Oh, and Ford executives weren't big fans, either. Newly revealed court documents in a California class-action lawsuit demonstrate the level of venom Ford employees, both big and small, reserved for the Blue Oval's infotainment system. An error caused Bill Ford's navigation system to crash, leaving the family scion stuck on the side of the road in an unfamiliar area. The documents, unearthed by Forbes, detail current CEO Mark Fields' aggravations with MFT, too. A mechanic emailed an image of a cracked infotainment screen on an Edge to one of Ford's top Sync engineers, Kenneth Williams, suggesting "Mark Fields may have been a little aggravated with the system." But Ford and Fields' issues are nothing compared to the woes of the engineers that had to work on MFT. In a collection of emails obtained by Forbes, one engineer called the system "a polished turd," while another simply said, "These poor customers." And after one engineer suggested using a photo of Ford's Oakville Assembly Plant – home of the Edge, Flex, Lincoln MKX, and MKT production – as a background for the system, one of his coworkers said in an email that someone should instead Photoshop the image to read "abandon hope all ye who enter here," the Detroit News reports. Another summed up the problem, saying: "Ford's quality reputation is completely on the line ... another model year with the same crap is not acceptable." MyFord Touch almost single-handedly torpedoed Ford's reputation in widely reported quality metrics, including JD Power and Consumer Reports. Ford responded with a refreshed Sync3, a wildly improved rethink of its infotainment system that is far more responsive and easier to live with every day. Related Video: News Source: Forbes, The Detroit NewsImage Credit: Ford Government/Legal Ford Lincoln Technology Mark Fields sync 3