Ford: F-250 Fx4 Lariat on 2040-cars

Auto blog

Ford recalls 1.48 million F-150s for transmission, plus other models

Weeks after recalling more than 800,000 F-Series pickup trucks for a fire risk, Ford has issued another separate recall for approximately 1.48 million 2011-2013 F-150s for a transmission fault. The six-speed automatics could unexpectedly downshift into first gear without warning. Ford and Lincoln tangentially issued much smaller recalls for the Mustang, Continental, Nautilus, and Navigator. According to Ford, some 2011-2013 model year F-150 pickups with six-speed automatic transmissions could "experience an intermittent loss of the transmission output speed sensor signal to the powertrain control module." This could potentially cause the trucks to temporarily downshift, which could be dangerous if it occurs while driving. Of the 1.48 million affected trucks, 1.26 million are in the U.S. while 221,000 are in Canada. Thus far, Ford knows of five reported accidents involving the issue. To remedy the problem, owners can take their trucks to dealers to update the power control module software. Ford also issued recalls for about 4,350 2019 Mustangs, Lincoln Nautiluses, and Lincoln Navigators in the U.S. and Canada due to a possible fault with the instrument clusters. Although there have been no reports of accidents, Ford says the instrument panel clusters assemblies might be blank or not turn out when the vehicle is started. Additionally, Ford issued a third recall for 28,200 2017-2019 Lincoln Continentals in the U.S. and Canada. Ford says silicon contamination might build up inside the door latch motor, causing it to malfunction. As a result, the door latch might not always fully engage, and the doors could possibly open unexpectedly. Despite no reports of accidents, Ford will remove and replace door latch assemblies on all doors for those affected by the defect. If any of these apply to a vehicle you own, contact Ford to discuss whether it is included in any of these recalls and have the vehicle checked out at a Ford dealership.

NHTSA closes Ford F-Series Super Duty steering probe without recall

The National Highway Traffic Safety Administration's investigation into 2008 Ford F-250 and F-350 Super Duty pickups, which was originally opened last year, has now ended without a recall. NHTSA was looking into steering failures on some 336,000 trucks.
The issue rested with the steering gear - NHTSA received five complaints of failures - which was redesigned in 2005. According to the report on the matter, investigators "found evidence of broken sector shaft gear teeth and piston damage consistent with incidents of single event overload."
NHTSA investigators, however, "found no evidence of fatigue or material property defects in any of the fractures. Analysis of complaint rates by vehicle build month showed no patterns indicating potential manufacturing quality issues and no difference before and after Ford introduced design changes to the input shaft and sector shaft seals in July 2007 to address potential leak concerns," according to the report, obtained by The Detroit News.

With contract expiration days away, UAW targets GM first for negotiations

The United Auto Workers union on Tuesday said that it would target General Motors as the first of the Detroit automakers for talks ahead of the current four-year contract's expiration on Sept. 14. This year's contract talks between the union and GM, Ford and Fiat Chrysler Automobiles NV are expected to be contentious as U.S. new vehicle sales are slowing and automakers face rising costs associated with the development of electric vehicles and self-driving cars. Rising healthcare costs, job security, profit sharing and the use of temporary workers are expected to be major sticking points. GM in particular has been a target of union ire since announcing the closure of five North American plants late last year. That move drew a wave of criticism, including from U.S. President Donald Trump. Trump has repeatedly prodded GM and last week said the No. 1 U.S. automaker should begin moving its operations in China back to the United States. "We are prepared and we are all ready to stand up for our members, our communities and our manufacturing future," UAW President Gary Jones said in a statement. In a statement, GM said, "We look forward to having constructive discussions with the UAW on reaching an agreement that builds a strong future for our employees and our business." The contracts come at a difficult time for the UAW, as a federal corruption investigation into the union continues to grow. Last week, the FBI conducted searches at Jones' home, a union retreat and multiple other locations, including the home of the union's previous president, Dennis Williams. To date, seven people linked to the union and the automaker have been sentenced in the government's corruption investigation. Reporting by Nick Carey.