2010 Ford F250 Lariat on 2040-cars

Auto blog

A cool boost to turbocharger performance

Since the advent of the forced-induction engine, we have been looking for ways to get every drop of performance we can. There are many approaches to getting additional power using better intercooling, water injection, or even adding nitrous oxide. One take on a short instant burst of power is being researched by Mahle and involves providing supercooled air to an engine, which allows it to burn a leaner fuel mixture and produce more power. The supercooling idea is not new and was examined by Ford in 1993 on the Mustang Mach III concept car, then brought up again in 2003 with the SVT F-150 Lightning concept. Ford called its system the SuperCooler; it was designed to work with any turbocharged or supercharged engine equipped with a water-to-air intercooler. The system on the Lightning concept used a small tank of antifreeze that was hooked up to the truck air conditioning compressor. The air conditioning compressor cooled the antifreeze down to about 30 degrees. The other side of the tank was hooked up to the air-to-water intercooler, which usually had a temperature over 100 degrees. Once the antifreeze was circulated from the tank into the intercooler, it would lower the intercooler temperature and provide for a cooler, denser air charge into the engine; the result was around 50 extra horsepower for a burst of about 30 seconds to a minute, depending on the size of the tank. The system for the Lightning was to be offered as a $750 option and would have been targeted towards drag racers and the like, as it could be used for a run down the drag strip and then re-cooled by the time the truck was back in line. The system was fairly non-intrusive – it only weighed about 25 pounds and did not require a new compressor or intercooler. But as with many concepts, it was ultimately scrapped. The technology was always stuck in the back of my mind, but with larger and more powerful engines being produced it could not find its place. With the advent of new fuel economy standards, we have seen small-displacement turbocharged engines pop up and they seem like the perfect candidate for this type of technology. Ford's EcoBoost 1.0-liter three-cylinder turbocharged engine, as used in the Fiesta and Focus, is one such candidate for this technology. It would add a negligent amount of weight but could provide a boost of 10 to 20 horsepower when needed, like merging onto the highway or catching up to traffic.

Ford recalls 300,000 Crown Vics over lighting module

The Basics: Ford is recalling 312,814 units of the Crown Victoria and Mercury Grand Marquis sedans from the 2003-2005 model years. They were built at the St. Thomas Assembly Plant between Oct. 3, 2001, and Aug. 2, 2005. Ford says 296,004 of those units are located in the United States, with another 14,714 in Canada and 2,096 in Mexico. The Problem: The solder joints on the lighting control module could crack, depriving the headlamps of the power they need to light the way ahead. That could increase the risk of a crash, particularly at night and in other low-visibility situations. Injuries/Deaths: Ford reports that it is aware of 11 accidents that resulted from the problem, leading to one injury described as "minor." The Fix: The manufacturer is instructing dealers to replace the entire lighting control module. If You Own One: Make sure your headlights are working before getting under way. If they're not, avoid driving under low-light conditions, including at night, in heavy precipitation, or in fog. Ford Issues Three Safety Recalls and One Safety Compliance Recall in North America DEARBORN, Mich., Dec. 22, 2015 – Ford Motor Company is issuing three safety recalls and one safety compliance recall in North America. Details are as follows: Ford Motor Company issues safety recall for certain 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles to replace lighting control module Ford Motor Company is issuing a safety recall for approximately 313,000 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles to replace a lighting control module. The solder joints on the module could crack and interrupt power to the headlamps – increasing the risk of crash at night. Ford is aware of 11 reports of accidents and one report of a minor injury related to this issue. Affected vehicles include certain 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles built at St. Thomas Assembly Plant, Oct. 3, 2001 through Aug. 2, 2005. There are a total of 312,814 vehicles that might be affected in North America, including 296,004 in the United States and federalized territories, 14,714 in Canada and 2,096 in Mexico. Dealers will replace the lighting control module at no cost to the customer. Ford issues safety recall for certain 2016 Ford F-650 and F-750 vehicles to replace rear air brake chamber Ford is issuing a safety recall for 177 2016 Ford F-650 and F-750 vehicles to replace the rear air brake chamber.

Hot Wheels' 2022 Green Speed cars bring EVs to small scale

With more and more EVs hitting the market, it was only a matter of time before the new breed of cars would find representation in diecast form. For 2022, Hot Wheels is coming out with a new Green Speed series that puts the spotlight on a diverse lineup of electric cars. The five-car series features a fun mix of EVs from different manufacturers and in a wide range of styles. Some are completely bone stock. For a traditional luxury sedan, there's a Lucid Air in silver, complete with glass (or in this case, clear plastic) canopy. For fans of Teutonic 4-door "coupes" there's the Audi RS e-Tron GT in Daytona Gray. Ticking the truck box is a Hummer EV in a yellow that can only be described as a throwback to the H3. But because this is Hot Wheels, there are "hot-rodded" variants in the lineup as well. Rather than just a regular Nissan Leaf, they've elected to cast the carbon fiber-bodied NISMO RC 2.0 race car. Likewise with Ford, instead of the standard Mustang Mach-E, they've gone with the Mustang Mach-E 1400 drift car. This isn't the first time Hot Wheels has put out a Green Speed series. The line debuted in 2016 but reflected the limited EV choices in the real car market at the time. The only non-fantasy cars in the series were a first-gen Tesla Roadster, a Tesla Model S, and Chevy Volt. Hot Wheels revisited the line again in 2019, this time adding a Tesla Model 3 and a Porsche Panamera Turbo S E-Hybrid Sport Turismo. Hot Wheels also makes other mini EVs that don't fall into this specific line of models. If you want to collect 'em all, there's the second-generation Tesla Roadster concept, Cybertruck, Jaguar I-Pace, Pininfarina Battista, Porsche Taycan, and a Volkswagen ID R. Similarly, Matchbox has released a version of the Tesla Roadster with sustainable packaging to boot. If you must have an old school gasoline burner, Hot Wheels has plenty of options for you too, like, say, this snazzy FJ60 Toyota Land Cruiser. The 2022 Hot Wheels Green Speed series should be on shelves at your local retailers now. Related Video: