1960 Green Ford F-100 Panel Van / Truck. Project Car! on 2040-cars

Auto blog

Ford reports 58% drop in Q2 profits on European losses

Ford Motor Company announced Wednesday that it has posted a $1 billion profit for the second quarter of 2012. That sounds like good news for the Blue Oval, until you take into account that Ford posted a $2.4 billion profit for Q2 a year ago. That is a substantial 58 percent loss.
Ford also posted $465 million in international losses, with $404 million of those losses coming directly from Europe. The automaker also increased its European loss projections to $1 billion for 2012, due in large part to the economic crisis overseas, which has resulted in increased unemployment and decreased consumer confidence.

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

Ford, GM still doing new business with Takata amidst airbag crisis

Lengthy vehicle development times make it difficult for automakers to cut and run from the supplier. You might expect automakers to be fleeing any connection with beleaguered supplier Takata in the wake of the company's exploding airbag inflator crisis. After all, with a Senate hearing, pending lawsuit, plummeting stock value and demand for a national recall, the tier-one supplier isn't at its strongest right now. However, years of cooperation mean that automakers are standing by Takata, and necessity may be playing a role, as well. About 39 percent of Takata's business comes from airbags, and seatbelts make up another significant chunk of the operation too, says Bloomberg. The long-term relationships and lengthy vehicle development times make it difficult for automakers to cut and run from the supplier. "Takata has so much product breadth that I don't really see that they could just disappear," said AutoPacific analyst Dave Sullivan to Bloomberg. For example, Takata helped develop the unique front center airbag with General Motors in models like the Chevrolet Traverse and Buick Enclave. Outside of safety tech, it is also a partner with Ford on the adaptive steering system available on the upcoming 2015 Edge. These long-lasting partnerships make change difficult now that there's a problem. According to Reuters, automakers claim it would take a year or longer to set up with a different supplier for replacement airbag inflators. Switching to a completely different part for the repairs might not be a viable option either, because of the engineering time needed. BMW is taking action, though. According to Reuters, the Bavarian brand is working with the supplier to move inflator production from Monclova, Mexico, to a Takata factory in Freiburg, Germany. The Mexican plant may be the source of some of the faulty parts. News Source: Bloomberg, ReutersImage Credit: Jens Meyer / AP Photo BMW Ford GM Safety Takata airbag recall