1956 Ford F-100 on 2040-cars

Auto blog

Ford recalls nearly 200,000 Expeditions and Navigators for fire risk

Ford is recalling 2015-2017 Expeditions and 2015-2017 Lincoln Navigators because the front blower motor could fail and cause a fire. In total, 198,482 Expeditions and Navigators will be recalled. In the official recall documents posted by NHTSA, Ford says that it “has not identified the cause of this condition.” However, Ford also says it is currently aware of 25 fire allegations related to the blower motors on these vehicles. Despite not strictly identifying the cause of blower motor fires, Ford put forth a theory in its fieldwork analysis of the issue.  “In June 2022, based on component analysis, Ford Engineering theorized that a mispositioned blower motor brush holder spring could cause an internal short or localized heating of the brush spring or holder. It is believed that when a fire initiates on the blower motor, it does so at the positive brush holder location. The variable blower controller would remain operational and there would be no signs of an overheated relay. Field data indicates that this concern typically occurs at a higher time in service, and on vehicles with higher mileage.” Since the blower motor is located on the passenger side interior behind the glovebox, the fires that start are interior fires. Ford isnÂ’t aware of any accidents related to this issue, but there is one claim of burnt hands and fingers as a result of a fire. According to Ford, warning signs of an impending fire or failed blower motor include an inoperative fan, burning smell and/or smoke from the instrument panel vents while the vehicle is on. To remedy this situation, Ford is recalling the affected SUVs and replacing the blower motor assembly with a revised part. The new part uses a blower motor assembly design utilized on other applications. If folks with these SUVs experience any symptoms of blower motor failure before the new part becomes available, Ford says they can take their vehicle to the dealer to have it replaced with a part of the same design. Once the redesigned part becomes available, the dealer will then swap it in. Owner notification letters are expected to begin on September 12 this year. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.

10 of 18 midsize SUVs earn 'good' IIHS side impact safety rating

It's not terribly surprising that midsize SUVs earned better safety ratings than small SUVs in the latest side-impact tests performed by the Insurance Institute for Highway Safety (IIHS). Just how much better they scored, on the other hand, certainly raises an eyebrow. Ten out of 18 midsize SUVs earned the highest rating of 'good' in the stringent new test, altered for vehicles starting with the 2020 model year with a heavier barrier (4,200 pounds) that moves at a higher speed (37 miles per hour) and is fitted with a hard honeycomb frontal structure. By way of contrast, just one out of of 20 small SUVs earned a 'good' score.  SUVs that receiving 'good' scores were the Ford Explorer, Infiniti QX60, Lincoln Aviator, Mazda CX-9, Nissan Pathfinder, Subaru Ascent, Toyota Highlander, Volkswagen Atlas, Volkswagen Atlas Cross Sport and Volkswagen ID.4. For EV fans, it's worth noting the ID.4 was the only electric vehicle included in the test. The Buick Enclave and Chevrolet Traverse scraped away with 'acceptable' ratings while the Honda Passport, Honda Pilot, Hyundai Palisade, Jeep Wrangler 4-door, Kia Telluride and Nissan Murano were deemed merely 'marginal' in the tough new test. Only two models — the Mazda CX-9 and Volkswagen ID.4 — earned a "Good" rating in every test category.  Interestingly, the Jeep Wrangler would have scored a 'good' rating if it were equipped with side airbags for the rear seating positions. It would likely be an engineering challenge to equip its removable top and/or doors with airbags, but the lack of that safety feature allowed the head of the rear passenger dummy to hit the vertical support of the top. Otherwise, the Wrangler scored good ratings across the board. The new Ford Bronco, which makes more allowances for side-impact safety, has not yet been tested.  The popular Hyundai Palisade and Kia Telluride SUVs stand out in the test with 'poor' ratings for driver pelvis injuries. The Nissan Murano, a vehicle last redesigned for the 2015 model year, was the only vehicle tested that received a 'poor' rating for its structure and safety cage. Videos of the tests of 12 of these 18 SUVs can be found on the IIHS' YouTube page. Related video: Green Buick Chevrolet Ford Honda Hyundai Infiniti Jeep Kia Mazda Nissan Subaru Toyota Volkswagen Safety Crossover SUV IIHS Insurance Institute for Highway Safety

Ford patents a multi-touch version of its classic keypad

For decades, Ford has offered a keypad on the doors of their cars that would allow owners access with the right code. Amazingly, the keypad has survived almost unchanged except for a recent touch button version. A new patent from the Blue Oval shows the keypad may get a big upgrade soon. The first big change is that it looks like the keypad may move to the key fob. Although it might be possible to have it on the car itself as well, the patent only seems to focus on the key fob. In addition, the fob will now be a multi-touch pad similar to that of modern smartphones. This will allow for more diverse code entries, according to the patent's description. Instead of just a simple number code, owners could enter a code that involves swipes and keystrokes, and even simultaneous keystrokes. For instance, you could enter a code that requires swiping from 1 to 3, followed by holding 2 and 4 to unlock the car. The patent also seems to indicate that this keypad would then display unlock functions and other functions on the fob after the correct code is entered, thus making it more than just a way to unlock the car. As for the practical implications of this keypad system update, it could provide an added layer of security. If someone steals your keys, they would have to also know your access code to get into the car. Whether this would also help make the key and car harder to hack would remain to be seen, though. Another possible benefit could be the prevention of accidental lock and alarm button presses, although that likely isn't a common issue. There could be potential downsides as well. If used as an extra layer of security, the legitimate owner would have to punch in their code on the fob to get in, which would render proximity key benefits relatively useless. Moving the keypad to the fob would also mean owners couldn't get into their cars without having the key with them. We don't have any clues as to when this could become a feature, but it doesn't seem like it would be difficult to implement, so it could show up in the next few years. Related Video: News Source: United States Patent and Trademark OfficeImage Credit: Ford, United States Patent and Trademark Office / Ford Auto News Ford Lincoln Technology keyless entry