1956 Ford F-100 on 2040-cars

Auto blog

A cool boost to turbocharger performance

Since the advent of the forced-induction engine, we have been looking for ways to get every drop of performance we can. There are many approaches to getting additional power using better intercooling, water injection, or even adding nitrous oxide. One take on a short instant burst of power is being researched by Mahle and involves providing supercooled air to an engine, which allows it to burn a leaner fuel mixture and produce more power. The supercooling idea is not new and was examined by Ford in 1993 on the Mustang Mach III concept car, then brought up again in 2003 with the SVT F-150 Lightning concept. Ford called its system the SuperCooler; it was designed to work with any turbocharged or supercharged engine equipped with a water-to-air intercooler. The system on the Lightning concept used a small tank of antifreeze that was hooked up to the truck air conditioning compressor. The air conditioning compressor cooled the antifreeze down to about 30 degrees. The other side of the tank was hooked up to the air-to-water intercooler, which usually had a temperature over 100 degrees. Once the antifreeze was circulated from the tank into the intercooler, it would lower the intercooler temperature and provide for a cooler, denser air charge into the engine; the result was around 50 extra horsepower for a burst of about 30 seconds to a minute, depending on the size of the tank. The system for the Lightning was to be offered as a $750 option and would have been targeted towards drag racers and the like, as it could be used for a run down the drag strip and then re-cooled by the time the truck was back in line. The system was fairly non-intrusive – it only weighed about 25 pounds and did not require a new compressor or intercooler. But as with many concepts, it was ultimately scrapped. The technology was always stuck in the back of my mind, but with larger and more powerful engines being produced it could not find its place. With the advent of new fuel economy standards, we have seen small-displacement turbocharged engines pop up and they seem like the perfect candidate for this type of technology. Ford's EcoBoost 1.0-liter three-cylinder turbocharged engine, as used in the Fiesta and Focus, is one such candidate for this technology. It would add a negligent amount of weight but could provide a boost of 10 to 20 horsepower when needed, like merging onto the highway or catching up to traffic.

2016 Ford Explorer revealed with new 2.3-liter EcoBoost

A 2.3L EcoBoost four-cylinder takes over where the old 2.0 left off, making 270 hp and 300 lb-ft.
Right now, around 23 percent of all Ford vehicles sold in the United States is a utility vehicle. By 2020, Ford expects that figure to increase all the way to 29 percent. Put simply, SUVs and crossovers are very big business at Ford. So, when it comes time to update the Explorer, Ford's original sport utility vehicle, you can be sure that a whole heck of a lot of effort goes into the process.

Feds Probe Power Steering In 938,000 Ford Midsize Cars

U.S. safety regulators are investigating complaints that the power-assisted steering can suddenly fail on three Ford midsize car models. The probe covers 938,000 Ford Fusion and Lincoln MKZ cars from the 2010 through 2012 model years, as well as the 2010 and 2011 Mercury Milan. The National Highway Traffic Safety Administration says it has received 508 complaints alleging that the cars lost power-assisted steering, causing increased steering effort. Four complaints say the problem caused crashes, but no injuries were reported. The agency says in documents posted Monday on its website that in many cases, a warning message appeared as the failure happened. Restarting the car corrected the problem in some cases, but the problem returned in others. The agency says it will check the scope and frequency of a problem. It could seek a recall. Ford says it's cooperating with the probe. Shares of Ford Motor Co. rose 6 cents to $14.65 in morning trading Monday. Its shares are down 14 percent over the past year. Related Gallery Our Favorite Hot And Sporty Cars For 2015 Recalls Ford Lincoln NHTSA Ford Motor Company power steering mercury milan investigation