03 4x4 4wd Gold 4.0l V6 Automatic on 2040-cars

Auto blog

Feds open investigation into Chevy Express, Ford Freestar rust issues

'Tis the season... for road salt. And with that, comes rust. And what does rust bring? Well, for Ford and General Motors, a National Highway Traffic Safety Administration investigation. According to The Detroit News, NHTSA is looking into potential recalls issues with Chevrolet Express vans and Ford Freestar minivans.
The feds have received five complaints that rust has caused leaking fuel filler pipes on 2003 Express vans. Separately, seven complaints have been filed over excessive rust in the rear wheel wells of 2004 Ford Freestar and Mercury Monterey minivans. The Freestar and Monterey went out of production in 2007. Neither issue has resulted in any crashes or injuries, according to the report.

2014 Ford Cobra Jet announced with new colors, parachute mount

Ford's drag-strip-ready Mustang Cobra Jet is back for 2014, and it's sporting a few changes to make it even better - both in competition and while sitting still. Rolling off the assembly line ready for duty in the NHRA Stock or Super Stock classes, production of the 2014 Cobra Jet is limited to just 50 units.
Racing upgrades for 2014 include the addition of a new three-speed transmission and a parachute mount, and while these will make the car better in the quarter mile, the Cobra Jet's new colors will make it look better tearing down the track. Buyers can now get their racecars painted up in Gotta Have-It Green or a custom, Cobra Jet-exclusive matte black hue. Ford and Ford Racing have already teamed up to make this an incredible factory drag racer with a full rollcage, massive Hoosier slicks, a race-tuned suspension setup and a supercharged 5.0-liter V8. Now, if only wheelie bars came standard...
Unlike the confusing third-party ordering system announced for the COPO Camaro, all you need to snatch up a 2014 Cobra Jet is $97,990 and good timing (as the cars will be sold on a first-come, first-served basis). Ordering opens up next month with production commencing in July. Check out the press release below.

Ford recalls nearly 200,000 Expeditions and Navigators for fire risk

Ford is recalling 2015-2017 Expeditions and 2015-2017 Lincoln Navigators because the front blower motor could fail and cause a fire. In total, 198,482 Expeditions and Navigators will be recalled. In the official recall documents posted by NHTSA, Ford says that it “has not identified the cause of this condition.” However, Ford also says it is currently aware of 25 fire allegations related to the blower motors on these vehicles. Despite not strictly identifying the cause of blower motor fires, Ford put forth a theory in its fieldwork analysis of the issue.  “In June 2022, based on component analysis, Ford Engineering theorized that a mispositioned blower motor brush holder spring could cause an internal short or localized heating of the brush spring or holder. It is believed that when a fire initiates on the blower motor, it does so at the positive brush holder location. The variable blower controller would remain operational and there would be no signs of an overheated relay. Field data indicates that this concern typically occurs at a higher time in service, and on vehicles with higher mileage.” Since the blower motor is located on the passenger side interior behind the glovebox, the fires that start are interior fires. Ford isnÂ’t aware of any accidents related to this issue, but there is one claim of burnt hands and fingers as a result of a fire. According to Ford, warning signs of an impending fire or failed blower motor include an inoperative fan, burning smell and/or smoke from the instrument panel vents while the vehicle is on. To remedy this situation, Ford is recalling the affected SUVs and replacing the blower motor assembly with a revised part. The new part uses a blower motor assembly design utilized on other applications. If folks with these SUVs experience any symptoms of blower motor failure before the new part becomes available, Ford says they can take their vehicle to the dealer to have it replaced with a part of the same design. Once the redesigned part becomes available, the dealer will then swap it in. Owner notification letters are expected to begin on September 12 this year. Related video: This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings.