Ford Explorer Xlt Sport Utility 4-door on 2040-cars

Auto blog

Ford and Chrysler reducing summer plant shutdowns

Most domestic automaker assembly plants traditionally take a couple of weeks off during the summer. The shutdowns give each plant time for much needed repairs and maintenance, and in some cases, help better align production with demand. Not this year, though, as demand for many models is outstripping what Ford, Chrysler and General Motors plants can produce.
Ford has announced that it will shorten its annual summer shutdown for most North American plants from two weeks to one. The shorter shutdown will increase the carmaker's annual North American production by 40,000 units on top of the 200,000 extra units that it was already planning to produce this year versus last. Automotive News reports that Ford produced 2.8 million vehicles on this continent in 2012, and that output this year has already increased 13 percent through April.
Chrysler, meanwhile, is also operating at full tilt and plans to run some plants through the summer with no shutdown at all. Those not getting a break include Jefferson North where the Jeep Grand Cherokee and Dodge Durango are assembled, Toledo North that will assemble the new Cherokee, and Conner Avenue, home of SRT Viper production. Other assembly plants will be down for a single week, while all of Chrysler's engine and transmission plants except one in Indiana will continue operating with no shutdown this summer.

Ford F-150 EcoBoost in NHTSA probe for acceleration issue

According to Automotive News, the National Highway Traffic Safety Administration is launching a probe into 400,000 Ford F-150 models over possible acceleration problems. According to the article, NHTSA has received 95 reports "alleging incidents of reduced engine power during hard accelerations" on 2011 to 2013 F-150 models equipped with the company's 3.5-liter EcoBoost V6 engine.
Automotive News reports that Ford has issued three technical service bulletins "related to intermittent stumble/misfire on acceleration from highway cruise in humid or damp conditions," according to the government agency's documents. About one third of the 95 reports NHTSA has received cited humid or rainy conditions when these problems allegedly occurred.
These technical service bulletins have allowed dealers to address a "condition related to moisture accumulation in the charge air cooler during extended highway cruising at constant throttle in humid or damp conditions," AN reports, citing NHTSA documents. Furthermore, the TSB outlines details for "reprogramming the powertrain control module with the latest calibration and installing a new CAC and air deflector plate."

Ford gets out of car subscriptions, sells Canvas to rival Fair

Ford says it’s selling its Canvas subscription service to competitor Fair, getting out of the subscription game after less than three years. Terms of the deal were not announced. Ford acquired Canvas in 2016 as a wholly-owned subsidiary based in San Francisco as a service to pilot subscriptions to Ford and Lincoln vehicles, eventually rolling out to Los Angeles and Dallas. The company said it had amassed around 3,800 subscribers in that time, who will have the opportunity to join Fair when their current subscriptions end and will receive more information from both subscription companies. But that number pales in comparison with Santa Monica, California-based Fair, which claims more than 45,000 subscriptions in 30 markets since launching in 2017. Ford was always fairly quiet about Canvas, and Automotive News last year reported that Lincoln executives expressed surprise over soft demand, saying that subscribers were looking for short-term solutions and often dropped out after just a few months. Ford is also in cost-cutting mode under CEO Jim HackettÂ’s $11 billion restructuring plan. The Blue Oval joins Cadillac, which put its $1,800-a-month Book By Cadillac subscription service on ice late last year, citing higher costs and fewer customers than expected. Cadillac has pledged to eventually relaunch the service as a pilot in select cities, but mumÂ’s been the word since. More recently, VolvoÂ’s Care by Volvo subscription service has come under scrutiny from dealers and an investigation from the California Department of Motor Vehicles and has made changes to its program. Thought it also has added the XC60, XC90 and V60 to the list of available vehicles. Fair touts itself as a “commitment-free” solution, with all-inclusive plans covering 24-7 roadside assistance, routine maintenance, insurance and other perks. It uses a mobile app to get customers prequalified, and it analyzes their eligibility and targets an affordable range of monthly payments. Customers then shop for cars and sign up for one via an initial payment that ranges by vehicle type, with the ability to keep the cars as long as they want and drop the service at any time. It peddles used cars from more than 30 different brands, none more than six years old or with more than 70,000 miles on the odometer. Fair on Tuesday announced it has raised $500 million in loans from a group of creditors, including Mizuho Bank and Japan's SoftBank, as it looks to expand its leasing services to Uber drivers.