2013 Titanium Ecoboost Navigation Sunroof Remote Start Satellite Radio Sync on 2040-cars

Auto blog

Would you pay $17 a month to give your older Ford connectivity?

When it was first introduced in 2007, there was nothing like the original Ford Sync system, since it allowed car owners to connect and use a portable device better than anything that came before it. And because it was a brought-in/tethered and software-based system, Sync leveraged a device's connectivity and was easily updated. It took competitors awhile to catch up: Toyota Entune wasn't available until 2011, and Chevy MyLink didn't roll out until 2012. But now Ford is the one playing catchup since it stuck with the brought-in strategy while most other automakers were quicker to add connectivity via an embedded cellular modem. Ford initially installed 2G/3G modems in its small fleet of electric and plug-in electric vehicles starting in 2012 so that owners could keep tabs on charging. Embedded connectivity came to Lincoln in 2014, and Ford began adding onboard 4G LTE via Sync Connect to select cars starting with the Escape in 2015. To get more cars connected more quickly, last week the automaker rolled out its FordPass SmartLink solution that plugs into the OBD port of 2010 to 2017 model year vehicles. This lets owners retroactively get onboard Wi-Fi, set up a "geo-fence" to keep tabs on a car's location, receive vehicle health reports and allows remote engine starting and door locking/unlocking using a smartphone app, among other features. But to connect older Ford vehicles will cost owners $16.99 a month for two years, not including installation. Ford throws in 1 GB of data or a 30-day trial, whichever comes first, after which owners have to add the vehicle to their Verizon shared data plan, which supplies connectivity for SmartLink, or establish a new account. (Disclosure: Autoblog is owned by Verizon.) By comparison, GM's 4G LTE data plans start at $10 a month for 200 MB and goes up to $30 for 3 GB, and owners can also add a car to an AT&T shared-data plan. But OnStar doesn't have a separate monthly subscription for the embedded modem or an installation charge, and standard features via the RemoteLink Mobile App are free for the first five years of ownership. FCA's Uconnect Access service also uses an embedded modem to provide similar telematics features for $20 per month following a free one-year trial, while a la carte in-car Wi-Fi is offered for $10 per day, $20 per week or $35 per month.

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

FCA to skip summer shutdowns as automakers rev up U.S. assembly lines

DETROIT — Several of FCA's facilities will skip their usual summer shutdowns to get a jump on rebuilding inventory, the company confirmed early Wednesday.  The plants that will remain open include three in the United States (Jefferson North in Detroit, Toledo Assembly in Ohio, and Sterling Heights Assembly in suburban Detroit), one in Canada (Brampton Assembly in Ontario) and two in Mexico (Saltillo Truck Assembly and Saltillo Van Assembly).  This will allow dealers to address depleted inventory of popular trucks and muscle cars, Automotive News reports. Other facilities not named will observe their normal one- and two-week breaks.  Automakers are speeding up U.S. assembly lines to meet recovering demand, increasingly confident coronavirus safety protocols are working to prevent outbreaks in their plants but wary of the challenges workers face outside. Screening workers for COVID-19 using temperature scans and questionnaires, the automakers have detected some people who reported for work despite being sick. Some plants have been briefly shut down for disinfection, but so far, there has not been a major outbreak within a U.S. auto plant since most reopened May 18, company and United Auto Workers union officials said. The risk of an infection picked up outside a plant spreading along assembly lines remains a prime concern, however. An outbreak could shut down a factory costing a manufacturer millions of dollars a day. The disruption caused by the pandemic is creating other challenges as well. At Ford Motor Co's F-series pickup truck plant in Louisville, Kentucky, the company has given more than 1,000 workers leave related to COVID-19 concerns. It hired temporary workers to fill their jobs as the plant accelerates production of trucks critical to Ford's financial recovery. Demand for pickup trucks helped boost U.S. auto sales in May, and contributed to stronger than expected overall U.S. retail sales for the month. Officials of UAW Local 862, which represents workers at the Louisville plant, said a lack of child care was a significant issue for members. It had led many to stay away from the plant and collect increased unemployment benefits provided under the federal CARES coronavirus relief act. Ford has now begun arranging subsidized child care for UAW workers, Gary Johnson, the automaker's head of manufacturing told Reuters.