2008 Ford Escape Xlt Auto Sunroof Cruise Control 70k Mi Texas Direct Auto on 2040-cars

Auto blog

Ford Explorer, Jeep Grand Cherokee flunk IIHS passenger-side crash test

The Insurance Institute for Highway Safety (IIHS) has uncovered major safety-related problems while crash testing a number of popular midsize SUVs. Among those that scored an overall rating of "poor," the lowest possible score, are the Ford Explorer and Jeep Grand Cherokee. Both SUVs showed a high risk of injury to a front passenger during the IIHS' passenger-side small overlap front crash test. This test simulates what might happen if a car or SUV strikes an immovable object, like a telephone pole, at 40 mph and with roughly 25-percent of its front width. "Although some vehicles in this group offer very good protection, in other models, the airbags, safety belts and structure showed serious deficiencies," says IIHS chief research officer, David Zuby. "In those SUVs, a front-seat passenger would be at risk of injuries to the head, hip or leg in a right-side small overlap front crash." In the 2018 Ford Explorer, the front of the SUV showed the structure was "seriously compromised" during both driver- and passenger-side small overlap crash testing, according to the IIHS. The lower and upper door hinge pillar showed intrusion levels of 15 and 13 inches, while the door sill itself was pushed inward 6 inches toward the crash test dummy. The IIHS states these results indicate a high probability that a front occupant would suffer injuries to their right hip and lower left leg. The 2018 Jeep Grand Cherokee didn't fare much better. Not only did the Jeep exhibit 10 inches of intrusion at the lower door hinge pillar, the front passenger crash test dummy's head hit the dashboard through the front airbag. Worse still, the side curtain airbag didn't deploy and the front passenger door opened. The IIHS says there is a strong chance this would result in right leg injuries, along with the possibility of a serious head injury. Even vehicles that earned an "acceptable" in the small overlap front crash test showed definite room for improvement. The 2018 Honda Pilot, for example, showed good structural performance during the crash itself. But the front passenger crash test dummy's head slid off the deployed airbag and hit the dashboard hard, indicating a head injury might result in a similar real-world crash scenario. Two other SUVs that scored "acceptable" ratings included the 2018 Nissan Pathfinder and 2018 Toyota Highlander. Scoring top marks of "good," the highest rating, in these IIHS crash tests were the 2018 Volkswagen Atlas, 2018 GMC Acadia, and 2019 Kia Sorento.

Inside Ford's high-tech climate chamber

There are two ways an automaker can test its vehicles in extreme climates: it can send said vehicle around the world – from Death Valley to the Arctic Circle – in search of the harshest weather, or it can recreate those conditions in an enclosed environment. We're sure that many automakers undertake some combination of both, but in this latest video clip, Ford shows us around inside it's state-of-the-art climate chamber. At its Driveability Test Facility in Allen Park, MI – inaugurated in 2010 just across the street from the Roush Technology Center – Ford can simulate all sorts of extreme conditions. It can drop the temperature down to -40 degrees Fahrenheit or raise it up to 130, and take it up to a simulated 12,000 feet above sea level or drop it down to 280 feet below. blast it with 150-mile-per-hour winds. It can control the level of humidity, approximate the intensity of the sun and even blast the test vehicle with artificial snow, just like your favorite ski resort. The facility strikes us as an engineering feat as impressive as some of the vehicles it's used to test, but don't take our word for it – scope it out for yourself in this brief two-minute video clip, which even includes some helpful tips for winter driving this holiday season and beyond. News Source: Ford via YouTube Plants/Manufacturing Ford Videos Michigan winter

Ford expands air bag recall nationwide

Ford Motor Co. has agreed to government demands to expand a driver's side air bag inflator recall to the entire U.S. The move announced Thursday adds 447,000 Ford vehicles to the list of those recalled due to driver's inflators made by Japan's Takata Corp. The inflators can explode with too much force, spewing shrapnel into drivers and passengers. Ford's action puts pressure on BMW and Chrysler, the only two automakers that haven't agreed to national recalls. The National Highway Traffic Safety Administration made the demand of five automakers, saying the inflators are dangerous. Honda and Mazda already took their recalls national. Previously the recalls were limited to high-humidity states mainly along the Gulf Coast. The Ford national recall covers certain 2005 to 2008 Mustangs and 2005 and 2006 GT sports cars. The company also announced it would recall the same cars in Canada, Mexico and a few other countries. Thursday's announcement brings to just over 502,000 the number of Ford vehicles under recall for Takata driver's side air bags. The company said it knows of one accident and injury from the problems, in a 2007 Mustang in North Carolina. Dealers will replace the inflators at no cost to customers. Last month, NHTSA demanded that Takata and the five automakers recall driver's inflators across the nation.Takata and Chrysler have refused and could face legal action. BMW says it's still evaluating the demand. Takata hired the New York public relations firm Sard Verbinnen & Co. and took out full-page advertisements Thursday in newspapers including The New York Times, The Wall Street Journal and three German publications. The ads, featuring a letter from Chairman and CEO Shigehisa Takata, said the company will work with NHTSA and automakers to expand the recalls by increasing production capacity for replacement air bags. The company said it's exploring whether other companies' air bags can be used in replacement kits, and it's increasing testing to find the exact cause of the problems. "Takata will work in unison with automakers to advance our common goal of putting the safety of customers first," the letter said. But in documents filed with NHTSA, Takata refused to do a national recall, saying it's not supported by testing data. The company also said NHTSA didn't have the authority to order a parts supplier to do a recall, and that only automakers can conduct them.