Low Reserve V8 Mustang Coupe on 2040-cars

Auto blog

Ford, Volvo join Redwood in EV battery recycling push in California

Ford and Volvo will join battery recycling startup Redwood Materials in developing processes, starting in California, to collect end-of-life batteries from electric and hybrid vehicles and recover the materials for use in new batteries, the companies said Thursday. Redwood Materials, co-founded by former Tesla executive JB Straubel, formed an earlier partnership last fall with Ford to develop a “closed loop” or circular supply chain for electric vehicle (EV) batteries, from raw materials to recycling. On Thursday, Redwood Materials said it would work directly with dealers and dismantlers in California to identify and recover end-of-life battery packs. The materials in those packs will be recovered and recycled at Redwood Materials facilities in northern Nevada. U.S. automakers Ford and General Motors Co (GM) have said the battery recycling effort is crucial in efforts to develop a domestic supply chain to meet increasing EV demand. GM and battery partner LG Energy Solution last year announced a partnership with startup Li-Cycle to recycle battery scrap material from Ultium Cells, the GM-LG joint venture that is building battery plants in Ohio, Tennessee and Michigan. Redwood Materials has similar partnerships with battery makers Panasonic in Nevada and Envision AESC in Tennessee, as well as with Amazon. Ford and Amazon are among the investors in Redwood Materials. Reporting by Paul Lienert in Detroit; Editing by Mark Potter Green Ford Volvo Green Automakers Electric

2017-19 Ford Super Duty trucks recalled for tailgates that could open

Ford announced two separate recalls today, though neither has resulted in any known injuries. The first recall, which deals with a tailgate malfunction, affects 261,617 examples of 2017-2019 F-250, F-350, and F-450 Super Duty pickups. The second, which anticipates the possibility of a fuel leak, affects 3,893 units of 2020 Explorer and 2020 Lincoln Aviator SUVs with 3.0-liter engines. Ford says tailgates might accidentally open on some 2017-2019 Super Duty trucks because of a short circuit. If the pickups have an electric tailgate latch-release switch on the tailgate handle, water might get into the wiring. If the water hits the right spots, a short circuit could cause the switch to release the tailgate latch. In a worst-case scenario where the tailgate opens while driving, contents of the truck's bed could fall out and create a safety hazard. Dealerships will fix the problem by modifying the tailgate frame wiring harnesses with jumper pigtails and install a new tailgate handle release switch. Of the lot, 231,664 trucks are in the U.S., and 29,953 are in Canada. The Ford recall number is 19S48.  The second recall is much smaller, involving fewer than 4,000 vehicles. In certain 2020 Explorers and Aviators with 3.0-liter engines, Ford says, "The convolute protective sleeve on the liquid fuel line is not long enough, which may allow for potential hard contact with the convolute-protected vapor fuel line. Over time, with vibration and engine roll, hard contact between the two fuel lines could cause the convolute on the vapor fuel line to rub through the plastic liquid fuel line." If that happens, it could be a fire risk and hazardous for drivers and passengers. Only 35 of those SUVs are in Canada, and the rest are in the United States. Dealers will fix the problem by replacing the defective convolute with a full-length piece and tying it down with a strap. The recall reference number for the Aviators and Explorers is 19S49. The recall adds to what has otherwise been a rocky early production phase for the new Explorers and Aviators.

Ford E-Series chassis cabs and cutaways to survive mass Transit onslaught

In March 2013, Ford announced we'd be getting chassis cab and cutaway versions of the Transit. Since incoming Transit vans will soon be rolling over the grave of the E-Series van, it was assumed that all E-Series models would go six feet under as well. According to a report from PickupTrucks.com, however, that's not the case, the report claiming that the highly modifiable E-350 and E-450 chassis cab and cutaway versions will continue being produced in Avon Lake, Ohio "at least until 2020."
Being decades old, the be-cabbed E-Series platform has found its way under an army of heavy-duty shuttle buses, work truck and ambulances. Ford spokeswoman Jessica Enoch verified the production horizon, telling Autoblog that the particular E-Series configuration "are a higher GVWR than the Transit chassis cab and cutaway (available this summer), which is more Class 2 and a new segment for us." So there you have it.