1930 Ford Model A Tudor Sedan Solid Car Needs Tlc on 2040-cars

Auto blog

How Ford made its 2015 Ford Mustang safer for toupee wearers [w/video]

Ford is ready to tell the story of its 2015 Mustang Convertible, the can't-miss bits being the easier, quicker and quieter roof operation, a more robust roof build for a coupe-like cabin noise, more trunk space, better visibility and reduced in-cabin buffeting. The top release system has been completely redesigned with a single, center-mounted latch on the windshield frame instead of the dual latches of before. The driver can now release the roof without having to lean over into the passenger space, after which the top goes down fully automatically with the press of a button. Ford doesn't say how long it takes to stow, but it's apparently done in half as much time as before, so figure around 8 seconds.
The roof uses a five-bow structure, with the fabric outer and full inner headliner sandwiching ten millimeters of insulation. Detailing work on the top has eliminated "unsightly folds" in the corners when the roof is up and made it more compact when down; its Z-fold assembly is 6.7 inches lower than before at its highest point when put down. Ford says the new electric drive internals make less noise when in operation, and the fully-finished droptop look is achieved with snap-in caps that flank the rear seating and stow in the trunk when not in use (the outgoing Mustang's top was higher and the front when folded and always looked like it was catching air and creating drag).
The compact roof and newly independent rear suspension setup in back means liberated trunk space, 11.4 cubic feet ready to swallow golf bags and tourist swag. You can read a lot more about it in the press release below, check it out in the short video of running footage and learn about the aerodynamic improvements made to the entire Mustang lineup that decrease drag and increase fuel economy.

Ford, Volvo join Redwood in EV battery recycling push in California

Ford and Volvo will join battery recycling startup Redwood Materials in developing processes, starting in California, to collect end-of-life batteries from electric and hybrid vehicles and recover the materials for use in new batteries, the companies said Thursday. Redwood Materials, co-founded by former Tesla executive JB Straubel, formed an earlier partnership last fall with Ford to develop a “closed loop” or circular supply chain for electric vehicle (EV) batteries, from raw materials to recycling. On Thursday, Redwood Materials said it would work directly with dealers and dismantlers in California to identify and recover end-of-life battery packs. The materials in those packs will be recovered and recycled at Redwood Materials facilities in northern Nevada. U.S. automakers Ford and General Motors Co (GM) have said the battery recycling effort is crucial in efforts to develop a domestic supply chain to meet increasing EV demand. GM and battery partner LG Energy Solution last year announced a partnership with startup Li-Cycle to recycle battery scrap material from Ultium Cells, the GM-LG joint venture that is building battery plants in Ohio, Tennessee and Michigan. Redwood Materials has similar partnerships with battery makers Panasonic in Nevada and Envision AESC in Tennessee, as well as with Amazon. Ford and Amazon are among the investors in Redwood Materials. Reporting by Paul Lienert in Detroit; Editing by Mark Potter Green Ford Volvo Green Automakers Electric

Ford investing $500M in engine plant for 2.7L EcoBoost production

Ohio is a hot area for Ford at the moment with the announcement just a few weeks ago that production of the next-generation F-650/F-750 medium-duty trucks would move from Mexico to the Ohio Assembly Plant in Avon Lake, Ohio. Now, Ford is investing $500 million to hire 300 workers at its Lima Engine Plant in Lima, Ohio, to add production of the twin-turbo 2.7-liter EcoBoost V6 for the 2015 F-150.
The latest investment will be used to add a new flexible engine assembly system and renovate 700,000 square feet of the plant for machining and assembly areas. The Lima factory already builds Ford's 3.5-liter and 3.7-liter Duratec V6 engines. The plant opened in 1957, and it's on track to build its 40 millionth engine later this year.
Ford claims that the 2.7-liter EcoBoost will offer V8 performance with better efficiency in the F-150. It comes standard with intelligent stop/start that doesn't activate when the truck is towing or in four-wheel drive, and it's made from a combination of compacted graphite iron and aluminum for low weight and high strength. The company says that V6 engines have already proven popular in the F-150 with 57 percent of trucks in 2014 being equipped with either the naturally aspirated 3.7-liter or turbocharged 3.5-liter EcoBoost engines.