2014 Sel New 3.5l V6 24v Automatic Fwd Suv on 2040-cars

Auto blog

New UAW boss Williams talks tough, vows 'no more concessions'

Dennis Williams, the newly elected president of the UAW, had some tough words for American automakers in his inauguration speech at the 2014 UAW Convention, striking down the possibility of any additional concessions from the 400,000-strong union.
"No more concessions. We are tired of it. Enough is enough," Williams said during his speech. UAW employees have not received a raise in nearly 10 years, according to Reuters.
Considering the recent strong results for Ford, Chrysler and General Motors, the union's demands are likely to carry a bit more weight in next year's negotiations. And considering Williams' tough stance, we could be in for some fireworks once negotiations commence.

Feds looking into Ford Explorer exhaust leak complaints

There may be a burgeoning problem with exhaust leaks in the 2011-2014 model year Ford Explorer. The National Highway Traffic Safety Administration is examining multiple complaints of a gasoline smell in the cabin of these SUVs. However, the exact cause of this problem is still unknown.
"The agency is reviewing all available data and will take appropriate action as warranted," said a NHTSA spokesperson in an email to Automotive News. Owners seem to generally complain on the regulator's website of the smell entering the cabin through the air vents. At this time, the government organization has not yet opened an official investigation into the problem, though. When it does begin inspecting vehicles, NHTSA posts a detailed breakdown of its public data online.
Similar problems have been reported about the Explorer in the past, though. In 2013, Ford issued a recall for the 2013 model year of the SUV due to a fuel leak that could cause drivers to smell a gasoline odor and repaired them again later for another possible leak. In response to Autoblog's questions, Ford responded via email: "We are not aware of a NHTSA investigation. We are currently reviewing the case and in the event that any action is required, we will address it promptly."

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.