Ford, F-450, White, Crew Cab, Rollback, Tow Truck, Wheel Lift, 7.3 on 2040-cars

Auto blog

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

Least reliable cars and trucks of 2022

Related: Most reliable cars and trucks of 2022   Every year, Consumer Reports ranks new cars based on their predicted reliability. We often see Toyota, Lexus, and a few other automakers near the top. But on the other side of the coin, the list of least reliable vehicles sometimes contains surprises.   The organization surveys its members to determine the vehicles that exhibited the most problems over the prior year. Owners are asked about creaks and rattles, the durability of parts and trim, and mechanical issues. Consumer Reports assigns a weight to each problem and then uses them to create a score, with 100 being the best. Some familiar names appear on the list of least reliable vehicles (in order with the lowest predicted reliability score at the top), but there are a few eyebrow-raising models, followed by CR's score: Ford F-150 Hybrid: 4 Hyundai Kona Electric: 5 Lincoln Aviator: 8 Nissan Sentra: 9 Ford Explorer: 16 Chevrolet Bolt: 17 Chevrolet Silverado 1500/GMC Sierra 1500: 19 Jeep Gladiator: 21 Mercedes-Benz GLE: 23 Jeep Wrangler: 24 Consumer Reports noted that sedans are the most reliable vehicle category and found that trucks are far lower on the list. That said, the survey showed that trucks from American brands tended to have better reliability scores, so it’s surprising to see GMÂ’s big two and the Ford F-150 on the list. Part of their problematic ownership experience could be due to the fact that all three trucks have received recent updates, and the Ford was completely redesigned for 2022. New tech, fresh drivetrain components, and other improvements can upset the balance of reliability and make newer models look less dependable than their older counterparts. Related video: Green Chevrolet Ford GMC Hyundai Jeep Lincoln Mercedes-Benz Nissan Car Buying Truck Crossover Hatchback SUV Electric Hybrid Sedan Consumer Reports reliability

Nelson Piquet and Nigel Mansell revisit bitter F1 rivalry in... Ford Fusion campaign?

Formula One World Champions Nelson Piquet and Nigel Mansell haven't been on good terms since the 1986 season, when Piquet joined Mansell at the Williams team and Piquet spent the year privately fuming about not being granted the status of number one driver. Things only got worse from there - even though Piquet won the title the following year with Williams, still partnered with Mansell, the fuming was a lot less private.
They're back together after a 25-year silence, in the city of Porto Alegre, Brazil to drive the new Ford Fusion. Called "Fusion Grand Prix," both men get the new Ford sedan, prepped to their liking - but still street legal, we assume - for a race to decide... well, who is faster behind the wheel of a Fusion.
There will be four episodes, with the first two having already aired. The third episode comes on January 29 and the race happens February 5. You'll find two video episodes and a press release below, but note - because it's a campaign for Ford Brazil, Piquet's dialogue in the vids isn't translated, so hit the Closed Captioning button to hear his side of the smack talking.