2015 Ford F350 Xl on 2040-cars

Auto blog

IIHS updates overlap test: 2 SUVs get good marks, 9 fare poorly

Vehicles in crashes keep occupants safe by deforming around the cabin in a way that maintains cabin integrity. The Insurance Institute for Highway Safety's moderate overlap test, introduced in 1995, has been a huge contributor to improved safety for front-row passengers in a crash. IIHS President David Harkey said, "Thanks to automakers’ improvements, drivers in most vehicles are nearly 50% less likely to be killed in a frontal crash today than they were 25 years ago." In the 'unintentional side effects' column, crash safety has gotten worse for passengers in the back seats. When carmakers reengineered the front crash structure to protect the driver, more crash forces got distributed throughout the rear. IIHS research claims rear passengers have a 46% greater risk of fatal injury than front-row passengers, but back-seaters haven't benefited from the same upgrades in safety as the front row. The IIHS updated its moderate overlap test to address the issue, putting 15 vehicles through the new regime. Two earned good ratings — the 2023 Ford Escape and the 2021-2023 Volvo XC40 — one was acceptable, three were marginal and nine were rated poor. Every one of the crossovers sampled got good marks for all passengers in the original test. That test sees 40% of vehicle's width on the driver's side impacting an aluminum honeycomb barrier at 40 miles per hour. The updated test puts a crash dummy representing small woman or 12-year-old child in the seat behind the driver, the dummy's sensors and grease paint measuring the effectiveness of the restraints and the forces a human body would need to endure. To achieve a good rating, the "measurements must not exceed limits indicating excessive risk of injury to the head, neck, chest, abdomen or thigh." An institute engineer said, "In real-world crashes, chest injuries are the most common serious rear-seat injuries for adults." The sensors and video evidence showed back seat dummies in the Escape and XC40 endured minimal risk of injuries from excessive crash forces, from submarining under the seat belt, or from unwanted interaction with the side curtain airbag.   The Toyota RAV4 scored acceptable. The second-row dummy also endured minimal risk of injury to the chest and lower extremities. However, the lap belt slipped upward in a way that could increase abdominal injuries, and after the dummy's head dipped during crash impact, the head came back up between the rear curtain airbag and rear window.

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

Chris Harris checks out Ken Block's Hoonicorn '65 Mustang

Ken Block's Hoonicorn, which stars in Gymkhana Seven, might still bear a passing resemblance to a vintage 1965 Ford Mustang, but underneath the skin, the car is one of the baddest custom machines to ever do a smoky burnout on the road. The ever enthusiastic British auto journalist Chris Harris is now showing what really makes Block's new ride tick on video, and Harris even gets to go for quite a ride. The only Mustang components really left on the Hoonicorn are the A-pillar, B-pillar and roof, according to Harris. Everything else is ditched to create Block's ultimate Gymkhana tool. The 845-horsepower, 6.7-liter Rousch Yates V8 sits behind the front axle, and the grunt is routed to all four wheels through a Sadev gearbox usually found on Dakar Rally vehicles. The whole drivetrain is packed with cool little touches; like that giant handbrake that also disconnects power from the front wheels when in use. The superlatives about the Hoonicorn could go on forever, but settle in and let a very excited Harris tell you about just some of them. He's like a kid in a candy store here, and the look that combines surprise, fear and joy during his ride with Block is the kind that lacks a suitable word in the English language.