2023 Ford F-150 Raptor R on 2040-cars

Auto blog

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

2014 Ford Fiesta ST

I'm not overly inclined to professional jealousy, as a rule. Sure, I go a bit green around the eyes when Ramsey draws the 911 GT3 trip to Weissach, Harley is tapped-in to drive a completely stunning Porsche 911 by Singer, or, you know, Drew Phillips gets to shoot a Lamborghini Veneno in the middle of a desert like some sort of sheik. I hate you guys...
Honestly though, one of the new car events that dug me the most, was when our Steven J. Ewing got to fling the Ford Fiesta ST around some hot corner of Europe. What goes around comes around, I suppose, as Mr. Ewing himself espoused an envious nature of the Focus ST trip that came before.
The good news in all this covetous intra-office behavior? All the cars mentioned, and specifically the Fiesta ST, are just wonderful to drive. I can say that with more confidence than ever now, having joined Ford for a good bit of Fiesta-flinging myself. In my case, the locale was slightly more pedestrian (Michigan not Portugal), and the car in question was the five-door version of the Fiesta ST that we get here in The States, as opposed to the three-door number they get across the pond.

Ford taken to task by gov't for Chicken Tax end-around

Ford is in a bit of a pickle for importing and selling Turkey-built Transit Connect cargo vans as passenger vehicles in the US, then converting them to commercial-vehicle specification stateside in an effort to bypass a 25-percent tax imposed on vehicles imported for commercial use. Automakers are required to pay a 2.5-percent tax on imported passenger vehicles.
The Blue Oval got into trouble for this in a January ruling in which U.S. Customs and Border Protection officials asked Ford to stop the practice of importing the Transit Connect vehicles with passenger seats, then removing and shredding them. Now Automotive News reports that Ford is appealing the ruling. The 25-percent "Chicken Tax," as the tariff is often called, is 50 years old and was enacted as a response to a German tariff on chickens. Like Ford, Chrysler bypasses the higher tariff, but it does so in a different manner. It partially disassembles Sprinter cargo vans before shipping them to the US, then rebuilds them at a plant in South Carolina.
But the ruling against Ford's strategy states that it "serves no manufacturing or commercial purpose" and is there to "manipulate the tariff schedule," Automotive News reports. As Ford's appeal goes through, it is importing the Transit Connect and paying the higher tax, hoping for a favorable outcome and planning to build the next-generation Transit Connect, which it plans to launch before the end of the year, in Spain.