2014 Ford F150 on 2040-cars

Auto blog

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

McLaren, Koenigsegg, Toyota, Ford, Dodge and Corvette Lego kits announced for 2021

Lego has announced a slew of car-themed sets for 2021. The six kits comprise nine vehicles and fall under the brick pusher's Speed Champion line of official OEM-licensed kits. News of their arrival comes from German toy retailer JB Spielwaren's pre-order listings, which show three single-car sets and three dual-car sets of matched marques. Starting with the McLaren Elva roadster, the kit consists of 263 pieces and is finished in blue. It seems to have a difficult time capturing the curves of the real-life Elva, but there's only so much you can do with a bunch of plastic blocks. Lego has made several other McLaren kits before, including the Senna, 720S, and a more advanced Senna GTR for the Technics line. Next up is the Koenigsegg Jesko, made up of 280 pieces and finished in white. Though the real-life Jesko is still curvy, this kit does a better job of replicating its aggressive maw, vents and cantilevered rear wing. Rounding out the single-car sets is the 299-piece Toyota GR Supra in yellow. This marks the first time Toyota has lent their license to Lego. Again, it struggles a bit to represent the curvy Supra, relying on printed details like logos and headlights to identify. On the other hand, the Chevrolet two-car does a stupendous job with the 1968 Corvette. The C3 is instantly recognizable as such. The C8-R race car it's paired with suffers from the same issues as some of the previous cars, though. The set contains 512 pieces, and funnily enough the C8 driver has short hair while the C3 driver sports a period-correct wavy mane. The next set is a 627-piece Mopar-themed pair, including a purple (Plum Crazy?) 1970 Dodge Challenger T/A and an SRT top fuel dragster. The race car is spot on, but the Challenger was probably tough to make given the width restrictions. It looks a couple of pegs too narrow compared to the wide proportions of the real deal. Last but not least, the Ford set contains a Bronco R and Ford GT Heritage Edition. Consisting of 660 pieces, the set does an excellent job of representing both cars. The GT looks faithful in its Gulf livery, and the Bronco R looks more like a real Bronco than the actual Bronco R race truck. All in all, it's always fun to see more Lego sets with real cars, and we're glad to see more manufacturers added to the roster. The single-car sets are recommended for ages 7 and up, while the double-car sets have an 8 years and up rating. Price in U.S.

GM, Ford, Toyota, Stellantis CEOs want EV tax credit cap lifted

For just over a decade now, the U.S. has had a federal tax credit worth up to $7,500 for buyers of electric cars and plug-in hybrids. The catch has been that, once 200,000 of them were claimed for a manufacturer, that credit would be phased out. Now, automakers are asking for this cap to be lifted across the board, specifically General Motors, Ford, Toyota and Stellantis. The request comes in the form of a joint letter to Congress (which you can read here), signed by the CEOs of each company. And the ask really is as simple as that. The automakers would like the cap lifted for all EV manufacturers, and instead have a sunset date for the tax credit put in place. Broadly speaking, they want it lifted because of concerns about rising costs from materials and supply chain issues, which can lead to higher prices and could discourage buyers from getting an EV. It would also put automakers back on an even playing field. GM reached its tax credit cap a few years ago, meaning that none of its EVs are eligible for the tax credit. So while it reaped the benefits early on, it now has something of a disadvantage to competitors with credits remaining, such as those that signed on to this letter. GM wouldn't be the only beneficiary. Tesla ran out of credits years ago, too. Nissan still has credits, but likely not for much longer, as InsideEVs reports around 190,000 Leafs have been sold in the U.S. as of April. So it will probably face a phase-out soon, just as the anticipated, and more expensive, Ariya is heading to market. Making this change would also seem like a good choice for continuing to stimulate EV sales, if that's what the government is looking to do. While EVs are now reaching parity in practicality and performance with gas-powered cars, having an additional financial incentive will surely keep them looking more attractive. And automakers can push EVs without fear of running out of credits early. Certainly some sorts of changes to the EV tax credit are likely. There are bills in the works focusing on cap changes as well as the amount of money available, and which vehicles are eligible. Credits up to $12,500 have been proposed, plus possible credits for used EV sales and restricting some credits to vehicles of certain price brackets. Of course, any changes will require some cooperation in a deeply divided Congress. Related Video: Government/Legal Green Chevrolet Chrysler Ford Toyota Electric EV tax credit