4wd 4dr Xlt Ford Explorer Sport Trac Xlt 4x4 Low Miles Crew Cab Truck Automatic on 2040-cars

Auto blog

NHTSA investigating 725k Ford, Mercury vehicles for stalling issue

Owners of Ford Escape, Mercury Mariner, Ford Fusion and Mercury Milan models, listen up. According to a report on Automotive News, the National Highway Traffic Safety Administration has opened an investigation into these four vehicles totaling an estimated 725,000 units. The investigation appears to center around a malfunctioning throttle body on non-hybrid models of the 2005-2012 Escape and 2011-2012 Fusion. With Mercury dying off after the 2011 model year, this probe will also apply to the 2005 through 2011 Mariner and the 2011 Milan. There has been some discussion around the Escape stalling issue for some time now, but this investigation appears to be larger in scope than before.
Though not a recall yet, NHTSA's Office of Defects Investigation (ODI) has received 123 complaints of stalling or surging vehicles, while Ford itself has logged 1,472 complaints. The investigation report, which is posted below, seems to indicate that a faulty circuit board for the throttle body could cause the vehicle to go into limp mode, which, according to NHTSA, could cause complaints of both stalling and surging.

Shelby boosts production of 575-hp Raptor on early demand

Shelby American unveiled its all-new Shelby Raptor at the New York Auto Show last month, saying that it would build just 100 examples of its off-road bad boy, a pickup priced at $17,995 over the cost of the donor Ford F-150 SVT Raptor. But the Las Vegas outfit apparently underestimated just how popular the supercharged 575-horsepower 4x4 would actually be.
Strong early demand reportedly has Shelby singing a whole new tune, as the company is now saying it will build upwards of 500 units annually. While the increased production will likely make for at least 400 more happy owners, those who were on the original short list - possibly speculating on future values - might not be grinning as much. Needless to say, the company has assured everyone that each and every one of the modified Raptors will still be listed in the official Shelby registry.
Keep in mind that Ford isn't sitting idle on its trophy-truck-for-the-street, either. The company will reveal its own 2014 F-150 SVT Raptor Special Edition this month.

Ford and Chrysler reducing summer plant shutdowns

Most domestic automaker assembly plants traditionally take a couple of weeks off during the summer. The shutdowns give each plant time for much needed repairs and maintenance, and in some cases, help better align production with demand. Not this year, though, as demand for many models is outstripping what Ford, Chrysler and General Motors plants can produce.
Ford has announced that it will shorten its annual summer shutdown for most North American plants from two weeks to one. The shorter shutdown will increase the carmaker's annual North American production by 40,000 units on top of the 200,000 extra units that it was already planning to produce this year versus last. Automotive News reports that Ford produced 2.8 million vehicles on this continent in 2012, and that output this year has already increased 13 percent through April.
Chrysler, meanwhile, is also operating at full tilt and plans to run some plants through the summer with no shutdown at all. Those not getting a break include Jefferson North where the Jeep Grand Cherokee and Dodge Durango are assembled, Toledo North that will assemble the new Cherokee, and Conner Avenue, home of SRT Viper production. Other assembly plants will be down for a single week, while all of Chrysler's engine and transmission plants except one in Indiana will continue operating with no shutdown this summer.