2004 Ford Excursion Eddie Bauer Sport Utility 4-door 6.0l 4x4 on 2040-cars

Auto blog

IIHS Crash-tests Expose American Muscle Cars' Weaknesses | Autoblog Minute

Turns out American muscle cars aren?t that strong according to IIHS crash tests. The Insurance Institute for Highway Safety put three iconic American sports cars through a range of performance crash tests. Chevrolet Dodge Ford Autoblog Minute Videos Original Video crash test camaro challenger

Ford recalls 90,736 vehicles due to engine valve issue

Ford will recall 90,736 vehicles as engine intake valves in the vehicles may break while driving, the National Highway Traffic Safety Administration (NHTSA) said on Saturday. The recall impacts certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine, the NHTSA said. According to documents posted by NHTSA and sourced from the automaker, "The engine intake valves may break while driving, which can result in engine failure and a loss of drive power." Following an investigation that started in January, 2022, Ford found 22 instances where "the engine intake valves fractured and fell into the combustion chamber of the engine causing catastrophic engine damage." The automaker's analysis continues: "Ford identified that the potential root cause of the failures was engine intake valve failure due to valves that exceeded the designed specification for hardness, were brittle, and more likely to fracture. Ford determined that this was due to the supplier’s grinding processes and the sensitivity of the intake valve material to grinding processes that were not within control specifications. The intake valve material was changed for vehicles produced after October 31, 2021." Fixing the problem will require replacement of the entire engine. "Dealers will inspect each vehicle to determine its cumulative number of engine cycles. For vehicles that do not meet the engine cycle threshold, dealers will accumulate high revolutions per minute (rpm) engine cycles per a service procedure. Engines will be replaced on vehicles that do not pass the engine cycle accumulation," Ford says.

2020 Ford Explorer safer than old model; crash test ratings short of Top Safety Pick

The 2020 Ford Explorer three-row crossover has improved on the outgoing model in many ways. According to the IIHS, it has also improved in a number of safety categories, but not enough to earn a Top Safety Pick award. The culprit is not the headlight performance for once. The Explorer's headlights were given an "Acceptable" rating, which would be sufficient for Top Safety Pick, if not Top Safety Pick +. Where the Ford falls short is in the front small overlap driver-side crash test, in which it got the second highest "Acceptable" rating. The IIHS requires a "Good" rating in this category, whereas an "Acceptable" rating on the passenger side would be, well, acceptable for Top Safety Pick. According to IIHS, Ford will be reviewing the results to figure out what the issue is, and it will likely make revisions to future Explorers to improve the result. Other than the one test, the Explorer performed admirably. It received a "Good" rating in all other crash categories except the passenger-side small overlap that was not tested. Both its standard and optional forward collision prevention systems had the highest "Superior" ratings, with the standard one preventing a collision with a car at speeds of up to 25 mph, and the optional one avoiding a collision at 12 mph, and "nearly" preventing one at 25 mph. Headlights are rated as "Acceptable" and so is access to child seat LATCH anchors. Also worth noting is that the Explorer's crash test ratings apply to its luxurious twin the 2020 Lincoln Aviator, meaning it also doesn't get a Top Safety Pick rating. The forward collision system performed the same as in the Ford, and the only difference between the two was in headlight performance. The Lincoln's standard headlights, included on the base, Reserve and Grand Touring trims, have the second-lowest "Marginal" rating, but the optional headlights for those trims, and the standard ones on the Black Label trim, received the "Good" rating. Among three-row Explorer competitors, the Honda Pilot, Hyundai Santa Fe XL, Kia Telluride, Nissan Pathfinder and Toyota Highlander all have a Top Safety Pick. The Hyundai Palisade, Mazda CX-9, Subaru Ascent, and the slightly smaller Kia Sorento and Volkswagen Tiguan all have a Top Safety Pick +. As for Lincoln Aviator competitors, the Cadillac XT6, Infiniti QX60, Lexus RX and Volvo XC90 get a Top Safety Pick. The Mercedes-Benz GLE-Class and two-row-only BMW X5 get the Top Safety Pick + rating. Related Video: