1990 Ford Hi-top Conversion Van on 2040-cars

Auto blog

Ford recalls more than 550,000 trucks and SUVs for various safety issues

Ford announced safety recalls for its current F-150 pickup along with several Ford and Lincoln crossovers early Wednesday. The recalls cover more than 550,000 vehicles and address various safety defects, ranging from a fire hazard to potential loss of braking power.  The most far-reaching of the recalls covers approximately 550,000 examples of the 2015-2018 Ford Edge and 2016-2018 Lincoln MKX, which may have been assembled with defective front brake jounce hoses (also commonly referred to as "flex lines"). These hoses run from fixed points on the chassis to the individual front brake calipers. Defective hoses could potentially rupture, allowing brake fluid to leak and resulting in a loss of braking function. Ford will replace the components in question with revised parts.  The next-largest recall is for roughly 3,000 2020 Lincoln Corsair crossovers. The affected models may have been assembled without proper clearance between their rear suspension springs and toe link brackets. The components could potentially make contact, wearing down the protective coating on the rear coil springs, allowing corrosion to occur over time. This corrosion could eventually lead to a failure of the spring. If this happens while the vehicle is being driven, it could result in a sudden change to the vehicle's handling characteristics, and the spring fragments could potentially cause further damage to the car or surrounding traffic.  Ford says owners will be notified that their Corsairs need to be inspected; if there is not adequate clearance between the rear suspension components, Ford's service technicians will remove material from the toe link bracket to allow for operation without contact.  The final (and by far the smallest) recall is for the 2020 F-150. Some units may have left the factory with the incorrect retention nut on the hot lead to the starter motor. Ford says it can cause increased heat generation or electrical arcing, which could potentially result in a fire. Ford says this issue is limited to just a few hundred examples sold in the United States. Dealers will inspect the vehicles and replace the nut if necessary.       

United States drivers buying fewer Mexican-made cars

Crossovers and pickup trucks are not only growing in market share, they're also more profitable than cars. A crossover on the same platform as a sedan retails for thousands more, despite similar components. It's one of the reasons we've seen automakers rapidly shifting production of their sedans and hatchbacks to Mexico, where cheap labor preserves the thin profit margins on these inexpensive vehicles. But as the market continues to shift in the United States, Mexico is getting burned by its lack of product diversity. The country's auto exports, which are heavy on cars, suffered a 16-percent drop last month, Automotive News reports. In total, year-over-year exports fell from 233,515 to 197,020 last month, while year-to-date exports are down by 7.4 percent, from 922,029 to 854,118. The number one culprit? America – which usually accounts for 75 percent of Mexico's exports – and its appetite for crossovers and pickup trucks bolstered by cheap gas prices. While Mexico does build some light truck models – AN specifically calls out the Ram 2500, Honda HR-V, GMC Sierra, and Toyota Tacoma as export leaders – the vast majority of vehicles rolling out of its factories are sedans and hatchbacks. In fact, the three biggest drops in Mexican exports came from companies whose south of the border factories only build cars – Ford (Fusion/Lincoln MKZ and Fiesta), Mazda (Mazda3), and Volkswagen (Golf and Jetta). Mexican Automotive Industry Association President Eduardo Solis told AN the export shortfall will likely be sorted out sooner rather than later, thanks to a pair of new factories – a Kia car factory and an Audi SUV plant – that are coming online by year's end. The two facilities will add around 100,000 vehicles to the country's export totals, which Solis said should leave the industry on the verge of breaking another export record in 2016. But how sustainable will these record-breaking years be? Slapping an "Hecho en Mexico" sticker on a new German SUV won't be enough to change the fact that Mexico's product mix is tilted too heavily towards body styles that are not growing in volume. Mexico's record-breaking export years probably aren't at an end, but we'd argue they're certainly under threat. News Source: Automotive News - sub. req.Image Credit: Omar Torres / AFP / Getty Images Plants/Manufacturing Ford GMC Honda Mazda RAM Volkswagen Truck Crossover SUV Mexico

Ford to announce Mulally retirement, Fields CEO as early as May 1

Ford CEO Alan Mulally may be about to announce his long-rumored retirement from the Blue Oval, according to a pair of insiders who spoke to Bloomberg. An official statement on the succession could arrive as soon as May 1. Chief Operating Officer Mark Fields is rumored to step up as the new CEO. The company is said to be readying the announcement soon to ensure an orderly transition of power, according to the insiders.
Mulally's retirement from Ford has been a hot topic for a while. He was seriously rumored last year to be leaving the automaker to take over as the CEO of Microsoft. The board even said at one point that it was okay with them if he stepped down early. However, the CEO maintained he would stay with the business through at least the end of 2014. Fields has been rumored as a frontrunner to take over the top spot at the company since he was promoted to COO.
For the moment, Ford isn't officially confirming any of these plans. "We don't comment on speculation. We do have succession plans in place for our key leadership. We take succession planning very seriously," said Susan Krusel, Ford Global News Manager, to Autoblog.