2012 Slt Lonestar Crew 4x4 Uconnect Voice Command Dual Transmission Oil Cooler on 2040-cars

Auto blog

Chrysler Recalls Over 566,000 Trucks, SUVs

Fiat Chrysler is recalling more than 566,000 trucks and SUVs in two recalls for malfunctioning fuel heaters that can cause fires and a software glitch can disable the electronic stability control. The recalls bring the newly merged company's total for the year to 6.4 million vehicles worldwide and 5.1 million in the U.S. as it continues to struggle with reliability problems. It was not immediately clear whether those totals were annual records. On Tuesday, its longtime quality chief abruptly left after Fiat Chrysler performed poorly in Consumer Reports magazine's annual reliability rankings. The largest of two recalls announced Wednesday covers almost 382,000 Ram 2500 and 3500 pickups and Ram 4500 and 5500 chassis cabs from 2010 through 2014. In trucks with 6.7-Liter Cummins diesel engines, corrosion on a fuel heater terminal could cause overheating, fuel leaks and fires. Chrysler is not aware of any fires or injuries. Owners could be warned by an odor of diesel fuel. Customers will be notified by letters starting in December. Dealers will install upgraded terminals and fuel heater housings could be replaced. The second recall covers more than 184,000 Jeep Grand Cherokee and Dodge Durango SUVs from 2014. A debris cover over a circuit board in the steering column control module can disrupt communications and disable the stability control. The problem was discovered when dealers started getting reports from customers that electronic stability control warning lights were coming on. Fiat Chrysler says it knows of no crashes or injuries caused by the problem. Technicians will upgrade software to fix the SUVs, and customers will be notified in December. Fiat Chrysler has issued 33 global recalls and 27 in the U.S. so far this year. Doug Betts, its longtime quality chief, left the company to pursue other options after Consumer Reports' survey-based rankings this year showed four FiatChrysler brands at the bottom of its list. Dodge, Ram, Jeep and Fiat performed worst of 28 brands ranked by the magazine. Company spokesman Eric Mayne said Fiat Chrysler's recalls average fewer than 200,000 vehicles each, below the industry average of 301,000. That means the company is responding quickly to problems, he said, adding that eight of its 27 U.S. recalls were announced before the company received any consumer complaints. Chrysler is not alone with a high number of recalls so far this year.

Junkyard Gem: 1994 Dodge Caravan with manual transmission

The K Platform saved Chrysler from certain doom after the company's 1979 bailout by the federal government, and one of the most successful K-based vehicles was the one that spawned the American minivan craze in 1984: the original Dodge Caravan/Plymouth Voyager. Built all the way through the 1995 model year, these K-Caravans or K-Voyagers could be purchased with a four- or five-speed manual transmission, but just a handful were sold that way. Here's an extraordinarily rare late 5-speed example, spotted in a San Francisco Bay Area wrecking yard. The shifter location is a little awkward, requiring the driver to reach back a bit more than would be the case in, say, a Dodge Shadow (which shared the same powertrain). It's too bad that Chrysler never offered these vans with five-on-the-tree manuals. Even though plenty of Mitsubishi-V6-powered front-wheel-drive Chryslers of the late 1980s and early 1990s were available with manual transmissions (e.g., the Chrysler Laser/Dodge Daytona or the Plymouth Sundance/Dodge Shadow), Chrysler minivan shoppers who wanted a stickshift had to take the four-cylinder engine (either a Chrysler 2.2/2.5 or, in the early years, a Mitsubishi 2.6 Astron). This one has the naturally-aspirated 2.5-liter engine that went into so many Plymouth Acclaims and Chrysler LeBarons. In 1995, it was rated at 100 horsepower, which made for stately acceleration with a full load of passengers. For the 1989 and 1990 model years, a 150-horse turbocharged Chrysler 2.5 with 5-speed was the high-performance minivan setup... and you should let us know if you find a factory-built one. This is only the second example of a manual-trans-equipped 1990s Chrysler minivan I have found in the junkyard (the first was this '93 Voyager), and both vans were lightly-optioned El Cheapo models with cloth seats and hand-crank windows; the manual transmission was a bit cheaper than the automatic in those days. At least this one has air conditioning. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. Advertising for these minivans tended to focus on price, price, price. Featured Gallery Junked 1994 Dodge Caravan with 5-speed View 18 Photos Auto News Dodge Minivan/Van dodge caravan

Chrysler recalling 2009-2010 Ram 1500, Dodge Dakota pickups over axle pinion nut

Chrysler is issuing a recall for the 2009 and 2010 Ram 1500 and Dodge Dakota pickup trucks due to improper installation of the rear axle pinion nut. According to the National Highway Traffic Safety Administration, a total of 44,300 trucks are affected by the recall, and there have been 12 confirmed incidents including one crash.
The issue on both trucks is that the pinion nut is loosening on some trucks due to a lack of thread adhesive, and it is causing the rear axle to lock up resulting in loss of vehicle control. NHTSA's recall notice says that eight incidents occurred at speeds over 35 miles per hour and most also exhibited driveshaft failures as well since the loss of the pinion nut would cause the gear to separate from the driveshaft. In one complaint, the driveshaft separated from the rear axle and punctured the gas tank.
Chrysler will begin sending out recall notices to affected owners in November, but scroll down to see the official NHTSA notice.