2005 Chrysler Crossfire Convertible Loaded New Tires Serviced Fun Sexy & Fast on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Junkyard Gem: 1990 Plymouth Voyager Turbo

There was a time when the word "TURBO" was king, and even Detroit minivans came with nervous, hair-drier-boosted engines and screaming TURBO badging. Why, some of them even had manual transmissions (sadly, not this van) and in the case of the 1990 Plymouth Voyager Turbo I spotted in a Denver self-service wrecking yard, a lysergic purple paint plus a Bordello Red interior. The first-generation Voyager minivan (not to be confused with the full-sized B-series Voyager van that preceded it) was a tremendous smash hit for Chrysler. Because it came from the K-Car platform, most of the powertrain options available for other members of the many-branched K Family Tree— from the Mitsubishi Astron to the Chrysler turbo 2.5— went into the Voyagers, Caravans, and Town & Countries. The turbocharged 2.5-liter four, rated at 150 horsepower, was an option for the 1989 and 1990 Voyagers. That doesn't sound like much today, an era in which the Voyager's descendants churn out close to 300 horses, but it was lunacy for a front-wheel-drive family hauler that weighed just over 3,000 pounds. And people eventually discovered they could be made far faster than stock. Voyager shoppers could get five-speed manual transmissiona with their Turbo 2.5 engines, though few did. Still, there were more Voyagers and Caravans with the 5-speed than you might think, in part because of the manual transmission's lower cost. The slushbox didn't conquer the Chrysler Corporation Minivan World until 1996. Nissan probably had the most vividly red interiors of the late 1980s and early 1990s, but Chrysler didn't lag far behind. Look at these acres of shiny red plastic and tough, red I Can't Believe It's Not Velour! Because minivans remain useful for decades, most of them have high odometer readings by the time they get junked. So at a little over 115,000 miles, this one may have had a busted speedometer cable. Speedometers reading better than 85 mph were legal after 1981, but perhaps Chrysler decided not to encourage lead-footed hoonery among minivan drivers. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. Auntie Entity pitching "the best-loved minivan in the world." Featured Gallery Junked 1990 Plymouth Voyager Turbo View 19 Photos Auto News Chrysler Dodge Automotive History Minivan/Van dodge caravan

Chrysler investing $20M in Toledo plant to support 9-speed auto production

In 2011, Chrysler announced a $72-million investment in its Toledo Machining Plant to modernize production of the eight- and nine-speed torque-converters for automatic transmissions made there. That upgrade work won't be finished until Q3 of this year, but Chrysler has already announced a further $19.6-million investment to increase production capacity for the nine-speeders.
The extra units will be necessary because the nine-speed transmission they'll be mated to is going into three popular models: it will debut on the 2014 Jeep Cherokee, then go into the Chrysler 200 and Dodge Dart. The company predicted that this year alone it would sell 200,000 units equipped with the nine-speed tranny, and it is spending some $374 million in addition to the investment in Toledo to upgrade production capacity for it.
The work attached to this new investment won't begin until Q3 of 2014, and it will be finished by the end of that year. There's a press release below with all the details.