2004 Chevrolet Monte Carlo Ls Coupe 2-door 3.4l on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

Next-gen Chevy Silverado and GMC Sierra may use carbon fiber

It's been generally accepted that the next generation of full-size GM trucks will use some sort of strong, lightweight material for the beds while retaining steel for the cab. While aluminum seems like the most obvious choice, according to Automotive News, the Chevy Silverado and GMC Sierra will incorporate both aluminum and carbon fiber in their beds. The publication cites sources from within GM, though it seems the introduction of this comparatively exotic material mix is still a few years off. While carbon fiber is both stronger and lighter than steel and aluminum, it takes significantly more time and money to produce, essentially relegating the material to small-volume cars. The main benefit for trucks is the resulting reduction in weight to improve fuel economy without sacrificing the tough, rugged capabilities truck buyers expect. The Ford F-150 made the switch to aluminum for the 2015 model year and it's proved highly successful. It seemed like it was only a matter of time before the competition followed suit. Automotive News says that the next-gen trucks will launch with aluminum beds and that it will take a couple of years before we'll see any carbon fiber incorporated into the design. Even then, only look for the composite material on higher-trim models, with a trickle down to lower-spec trucks possible further in the future. In 2011, GM announced it was working with Japan-based Teijin Limited on a carbon fiber reinforced thermoplastic. There's a good chance that material's introduction will be on trucks. Related Video: News Source: Automotive News Plants/Manufacturing Rumormill Chevrolet GM GMC Truck

Volvo and GM team with Amazon for in-car deliveries

Volvo and GM are the first automakers to pair their vehicles with a new service from Amazon that lets owners have their packages delivered inside their cars, without them having to be there. The service will initially be rolled out in 37 U.S. cities at no extra charge to Amazon Prime members with a Volvo On Call or OnStar account, and it works with same-day, two-day and standard shipping. It's intended as an alternative for people who don't want to risk having their package stolen from their front porch or receive deliveries at their workplace, and both automakers say it's an example of how they're embracing innovation as a way to make their customers' lives easier. Volvo released a video (above) showing how the service works. Users download the Amazon Key App (or " Ama-zin," as the narrator pronounces it) and link their Amazon Prime account with their Volvo On Call account — or OnStar, in the case of GM-branded vehicles. Once they register their delivery location in a publicly accessible location, users can select the "In-Car" option at checkout. They get a notification when the delivery is en route and once it's completed and the car is relocked. Volvo has been offering in-car delivery in certain European countries since 2015 through its Volvo On Call platform, which enables services like the ability to send calendar-based navigation destinations directly to the vehicle, find nearby gas stations and help locate the vehicle when you forget where you parked it. Volvo says the platform is now available in roughly 50 countries and covers more than 90 percent of its global sales. The service is compatible with 2015 or newer Volvo, Buick, Cadillac, Chevrolet and GMC vehicles. Volvo says it's available to the majority of Volvo owners, while GM says more than 7 million vehicle owners can qualify. The service is expected to roll out to more cities later. You can check eligibility at amazon.com/keyincar. Related Video: Buick Cadillac Chevrolet GM GMC Volvo Technology Infotainment Amazon connected car volvo on call e-commerce