1999 Chevrolet Malibu Ls Sedan 4-door 3.1l on 2040-cars

Auto blog

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

Chevy's 6.6-liter Duramax is pretty much all new

To say there's a heated battle in heavy-duty pickups is an understatement, with Chevrolet, Ford, and Ram constantly trading blows of increased torque, horsepower, and towing capacity. The latest salvo is the revised, more powerful turbo diesel 6.6-liter Duramax V8 in the 2017 Chevy Silverado. It has 910 pound-feet of torque, an increase of 145, putting it nearly level with the Ford Super Duty. Here's a closer look at where those gains come from. How exactly did Chevrolet add all that torque plus 48 horsepower? The automaker essentially took a fine-tooth comb to the entire engine. Chevy says it changed 90 percent of the V8, and the cumulative effect of those small changes adds up to big increases. As you might guess, the turbocharger is updated. The larger unit features electric actuation of the variable nozzle turbine (VNT), and what Chevy calls a double axle cartridge mechanism that separates the VNT moving parts from the housing. That helps with heat performance as well, with a claim that the exhaust side of the turbo can run continuously up to 1,436 degrees Fahrenheit. Helping that cause are six exhaust gaskets made of Inconel - an nickel alloy that contains chromium and iron – and upgraded stainless steel for the exhaust manifold. Despite having the same cast iron cylinder block, albeit with some minor enhancements, the engine has new cylinder heads, pistons, piston pins, connecting rods, and crankshaft, which have all been upgraded to handle 20 percent higher cylinder pressures. Alongside the increase in pressure, Chevrolet also increased the cylinder head's structure with a honeycomb design. The pattern features high-strength aluminum with dual layer water jackets that not only improve strength, but also optimize water flow for better cooling. For 2017, the cylinder head also benefits from integrated plenum that aids the engine in getting more air under heavy loads. The cylinder head isn't the only component to get a minor update, as the pistons have a larger diameter pin for improved oil flow. The same detailed improvements has been bestowed to the humble connecting rods (second in our hearts only to the inanimate carbon rod). The new design has the bolts oriented roughly 45-degrees to the rod instead of parallel. The angle split design, as it's called allows for easier passage through the cylinder.

GM plans new car family for global markets, $5B investment

Globalization remains all the rage in the auto industry, as manufacturers scramble to develop single vehicles that can easily be adapted to the world's disparate market places. Ford has been a champion of this movement, with its One Ford mandate, but now, its cross-town rival is getting in on the action, albeit on a smaller scale. General Motors has announced a $5-billion investment to develop a new Chevrolet-badged family vehicle for global growth markets, including Brazil, Mexico, India, and importantly, China. With the PRC listed as a target market for the new vehicle, it's no surprise that GM is teaming with its Chinese joint-venture partner, SAIC Motor, to develop the vehicle's architecture and engines. The first vehicles should be hitting dealers by 2019, with GM expecting to eventually move some two million units per year. "With a significant majority of anticipated automotive industry growth in 2015 to 2030 outside of mature markets, Chevrolet is taking steps to capitalize on that growth," GM President Dan Ammann said in the attached statement. "Strengthening Chevrolet's position through this major investment is consistent with our global strategy to ensure long-term profitable growth in the markets where we operate." GM is quite focused on developing markets for a new vehicle, going as far as to say that "mature markets" like the US aren't currently being considered for the new family vehicle. As for where it will be built, the press release specifically says it won't be exported to the US, meaning it will very likely be built abroad using parts from local suppliers. Read on for the official press release from General Motors. Chevrolet Strengthens Position in Growth Markets with $5 Billion Investment 2015-07-28 All-new vehicle family tailored to local customer requirements General Motors and SAIC Motor partnership further enhanced DETROIT – Chevrolet announced today it is investing $5 billion to strengthen its business in global growth markets through the development of an all-new vehicle family that will meet the rapidly changing demands of customers in these markets. "With a significant majority of anticipated automotive industry growth in 2015 to 2030 outside of mature markets, Chevrolet is taking steps to capitalize on that growth," said General Motors President Dan Ammann.