08 Chevrolet Express Turtle Top Bus Limousine Bus 29000 Miles 15 Passenger Bus on 2040-cars

Auto blog

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

Meet the mother-daughter team that's worked on almost every Chevy Volt

It's Mother's Day, and we're soft enough we love our mothers enough to share a new video from General Motors with you. In it, we meet Monique Watson (left) and Evetta Osbourne, a mother-daughter team that works at the Detroit-Hamtramck Assembly where GM makes the Chevy Volt (along with all of GM's other plug-in hybrids: the Opel Ampera, Holden Volt and Cadillac ELR). The two work side-by-side and have installed the lithium-ion battery pack on almost all of those vehicles - nearly 80,000 of them - since GM started making the pre-production Volts in 2009. In a prepared statement, Watson said that she likes working next to her mom, day in and day out, and they the two are totally in sync when it comes to putting the 400-pound, 16.5-kWh packs into the vehicle undersides. They two can also share stories throughout the day, and Watson said, "The arrangement has absolutely improved our relationship." Osborne started working at Detroit-Hamtramck in 1999, Watson since 2006. If you're driving a Volt today, you probably have them to thank for doing a bit of the work putting your car together. See a short video of them in action below. It's Always Mother's Day for Detroit-Hamtramck Duo Mother, daughter install lithium-ion battery pack in nearly all GM electric vehicles 2014-05-08 DETROIT – For Detroit resident Evetta Osborne, every day is Mother's Day. That's because she literally works side by side with her daughter, Monique Watson, at General Motors' Detroit-Hamtramck assembly plant. They have installed the lithium-ion battery pack on nearly every Chevrolet Volt, Opel Ampera, Holden Volt, and Cadillac ELR since production began. In fact, apart from vacation days and an occasional sick day, the mother-daughter duo has installed almost every battery pack since the Volt was in pre-production in 2009. The ELR launched earlier this year. All told – including Ampera – that's more than 80,000 electric vehicles. "We're a good team and our relationship is secondary when it comes to performing our jobs – but it's great to work alongside my daughter, said Osborne, a mother of five. Because the battery packs weigh more than 400 pounds each, automatic guided vehicles – robotic carts that use sensors to follow a path through the plant – deliver them just as the vehicle body structures glide into position overhead. The carts then lift the T-shaped packs, and Osborne and Watson guide them into the chassis and secure each one with 24 fasteners.

Junkyard Gem: 1987 Chevrolet Turbo Sprint

Fifteen years ago, I wrote my first-ever automotive article under the name Murilee Martin, and it didn't take me long to start writing about one of my favorite automotive subjects: the junkyard. Before I'd refined my system for documenting discarded vehicles, however, I shot a lot of boneyard photos that never got used. For today's Junkyard Gem, I have four shots from early 2007 of one of the rarest turbocharged machines of the 1980s: the Chevrolet Turbo Sprint. The Chevrolet Sprint was really a rebadged Suzuki Cultus, from the pre-Geo era when General Motors sold the Isuzu Gemini as the Chevrolet Spectrum, the Daewoo LeMans as the Pontiac LeMans and the Toyota Corolla as the Chevrolet Nova (soon enough, the Spectrum became a Geo, and the Nova became the Prizm). The second-generation Cultus appeared in 1988, becoming the Geo Metro on our shores the following year. The Turbo Sprint was available for just the last two years of the Sprint's 1985-1988 American sales run, and it appears that just a couple of thousand were sold; if I'd known at the time just how rare they were, I'd have shot more photos of this one at the now-defunct Hayward Pick Your Part. The turbocharged 993cc three-cylinder produced 70 horsepower, 22 better than the naturally-aspirated version. Since the Turbo Sprint weighed just 1,620 pounds (that's about 500 pounds lighter than a barely more powerful '22 Mitsusbishi Mirage), it was plenty of fun to drive. For 1988, the regular Sprint hatchback cost $6,380 while the Turbo Sprint listed at $8,240 (that's about $15,375 and $19,855 today, respectively). Believe it or not, a Turbo Sprint actually raced in the 24 Hours of Lemons 10 years ago, though it didn't end well. This ad is for the regular Cultus, not the Cultus Turbo, but the screaming guitars sound reasonably turbocharged. For the most part, Chevy Sprint marketing was all about cheap purchase price and stingy fuel economy… at a time when gasoline prices were cratering. Related Video: