1972 Elcamino Pro Street on 2040-cars

Auto blog

The real costs of keeping a Chevy Volt on the road

The release of the new, 2016 Chevy Volt is sure to bring a surge of used electric vehicles to the market as early adopters trade their older models in. Many of these cars are selling for a fraction of their original price, thanks in part to federal and state incentives that lowered the initial cost to the first owner, which opens these cars up to a whole new class of consumers. While the prices are getting attractive, potential buyers are still hesitant to buy a used EV due to uncertainty about service and repair costs, but there may be some good news on the horizon. The Chevy Volt comes with a battery warranty that is good for at least 8 years and 100,000 miles, but many of the Volts popping up on the market have passed that 100,000-mile mark. The threat of needing a new battery can be a deterrent, especially with some dealers quoting prices as high as $34,000 for a full "drive motor battery replacement." That sum is more than the MSRP of a 2016 model. Some of the fear of EV maintenance and repair comes from the mystery of the individual pieces that make up the drivetrain and charging system. If we take a look at the Volt in terms of analogs to a traditional internal-combustion vehicle, the outlook becomes a little more friendly. The Volt battery pack consists of three lithium-ion modules in a T-shaped arrangement, each of which can be serviced individually. Module 1 is made up of 90 cells and corresponds to GM part number 22954462, which retails for $3,258.33; module 2 is made up of 72 cells and corresponds to GM part number 22954463, which retails for $2,930.00; lastly, module 3 is made up of 125 cells and corresponds to GM part number 22954464, and retails for $4,933.33. These part numbers have been added to the dealer order systems but have not shown up in the distribution centers at this time. Although all three of the modules add up to a fairly large $11,121.66 total and are still on hold for dealer ordering, the good news is that in most cases these battery cell modules do not need to be replaced. There are many other individual pieces mounted on the battery pack that are serviceable, such as the Battery Energy Control Modules (BECM) and the Battery Interface Control Modules (BICM). These modules control and monitor the battery packs and charging system and have been known to fail while the lithium-ion battery cells are not at fault. Some have been replaced under warranty, but if you are stuck buying one they run about $255 a piece for the part.

Chevy Volt 'acceptable,' Nissan Leaf 'poor' in new IIHS safety tests

Ford C-Max Hybrid also scored "acceptable" rating. With US Nissan Leaf sales up almost 30 percent during the first half of the year, the only thing that might be able to stop the battery-electric vehicle is a good, stiff barrier. Unfortunately, thing's aren't always pretty when that happens in the real world, according to new tests from the Insurance Institute for Highway Safety (IIHS). Things with the Chevrolet Volt extended-range plug-in are a little bit rosier, though. The two plug-in vehicles were part of a batch of a dozen vehicles that just went through the IIHS's "small overlap" test, in which the driver's side front corner of the vehicle is crashed into a rigid barrier at 40 miles per hour. Out of the dozen, only the Mini Cooper Countryman was given a "good" rating. Five vehicles, including the Volt and the Ford C-Max Hybrid, were rated "acceptable," two were "marginal" and two, including the Leaf, were "poor." Plug-in vehicles are unique in the crash-test context because of their relatively large battery sizes. In the Volt's case, the driver had a "low risk" of injury, said the IIHS. But the Leaf's crash substantially pushed back the instrument panel and steering column, creating a scenario where the driver was "likely" to sustain leg injuries. The batteries in both the Leaf and the Volt passed safety tests specifically targeted at things like thermo and electrical properties and overall integrity. "Nissan is proud of the Leaf's 'Good' rating in all other IIHS tests, a 4-star NCAP rating from NHTSA and its IIHS Top Safety Pick rating in all previous years since the car's release," the company said in an e-mail sent to AutoblogGreen. "As for the performance of the 2014 Leaf in the 'small overlap frontal test,' Nissan will continue to review these and other results from the IIHS 'small overlap frontal test' as we seek opportunities for improvement." Check out the IIHS's press release and small car crash-test video footage below. Range of ratings: Small car ratings run the gamut in challenging small overlap front test The Mini Cooper Countryman is the only small car to earn a good rating among the latest group of 12 cars subjected to the Institute's small overlap front crash test. Two electric models and a hybrid also are in the mix, with varied results. The electric-powered Chevrolet Volt (with a gasoline engine "range extender") earns an acceptable rating, while its battery-electric rival, the Nissan Leaf, earns a poor rating.

GM follows Ford and Honda in skipping SEMA

The list of automakers skipping SEMA has become longer. First reported by Muscle Cars and Trucks, and confirmed to us by a company representative, General Motors will not have an official presence at the aftermarket show. It joins Ford and Honda in leaving the show. It will be a large hole in the show, with the GM brands typically filling a significant swath of available show space in one of the main halls. GM hasn't provided much explanation for the move, either. The GM representative provided Autoblog with the same statement that Muscle Cars and Trucks got: "GM has made the decision not to participate in the 2022 SEMA Show. The SEMA show has always inspired us, and accessories and performance parts remain an important part of our business." We also asked if we would see any sort of announcements around the time of the show — Ford said it has plans to share some things around that time — however, the GM representative said that the company has no immediate plans for announcements. Certainly things could change between now and the November show, though. SEMA had previously noted that other exhibitors would help fill in some of the space vacated by these major OEMs. Another OEM, Volkswagen, is returning to the show after an absence, which will also help with the display deficit. Related Video: