1970 Chevrolet Chevelle on 2040-cars

Auto blog

New Takata problem results in recall of 414 GM vehicles

An airbag-inflator rupture discovered by Takata during testing has resulted in a new recall affecting 414 vehicles from General Motors, including 395 of them in the US. This latest campaign covers 2015 model-year examples of the Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain. There are no reported breaks in any of these vehicles on the road, and the company estimates only one percent of them actually have the faulty parts. According to documents submitted to the National Highway Traffic Safety Administration (as a PDF), one side-airbag inflator failed a cold test at -40 Fahrenheit "releasing high pressure gas and propelling the separated components apart." The supplier told GM about the failure the next day. In these vehicles, the safety device might not only burst but the bag could inflate incorrectly, as well. GM and Takata say that a cause is not yet known, but they are "conducting an investigation." GM will begin notifying affected owners via overnight mail on Oct. 19. Dealers will replace the side airbag modules on all of the affected vehicles with new components outside of the suspect lot. All of the removed parts will also be collected for further study. Takata's faulty front airbag inflators have resulted in a serious scandal for the supplier. Initial figures indicated 34 million US vehicles are need of repair, though more recent figures have knocked that down to 23.4 million bad parts in 19.2 million automobiles. GM was already among the dozen automakers with models to fix, and some of its pickups were affected, along with the Saab 9-2X and Pontiac Vibe. GM Statement: General Motors is recalling 395 cars and crossovers in the U.S. because one of the front seat side air bags inflators may be defective. In the event of a deployment, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. GM is unaware of any incidents involving vehicles with these components, which were part of a lot in which one inflator failed acceptance testing at the supplier. Dealers will replace the side air bag module or modules in affected vehicles. Including Canada, Mexico and exports, the total population of the recall is 414, GM estimates 1 percent of the recalled vehicles may have the defect.

IIHS: High numbers of drivers treat partially automated cars as fully self-driving

WASHINGTON — Drivers using advanced driver assistance systems like Tesla Autopilot or General Motors Super Cruise often treat their vehicles as fully self-driving despite warnings, a new study has found. The Insurance Institute for Highway Safety (IIHS), an industry funded group that prods automakers to make safer vehicles, said on Tuesday a survey found regular users of Super Cruise, Nissan/Infiniti ProPILOT Assist and Tesla Autopilot "said they were more likely to perform non-driving-related activities like eating or texting while using their partial automation systems than while driving unassisted." The IIHS study of 600 active users found 53% of Super Cruise, 42% of Autopilot and 12% of ProPILOT Assist owners "said that they were comfortable treating their vehicles as fully self-driving." About 40% of users of Autopilot and Super Cruise — two systems with lockout features for failing to pay attention — reported systems had at some point switched off while they were driving and would not reactivate. "The big-picture message here is that the early adopters of these systems still have a poor understanding of the technologyÂ’s limits," said IIHS President David Harkey. The study comes as the National Highway Traffic Safety Administration (NHTSA) is scrutinizing Autopilot crashes. Since 2016, the NHTSA has opened 37 special investigations involving 18 deaths in crashes involving Tesla vehicles and where systems like Autopilot were suspected of use. Tesla did not respond to requests for comment. Tesla says Autopilot does not make vehicles autonomous and is intended for use with a fully attentive driver who is prepared to take over. GM, which in August said owners could use Super Cruise on 400,000 miles (643,740 km) of North American roads and plans to offer Super Cruise on 22 models by the end of 2023, did not immediately comment. IIHS said advertisements for Super Cruise focus on hands-free capabilities while Autopilot evokes the name used in passenger airplanes and "implies TeslaÂ’s system is more capable than it really is." IIHS in contrast noted ProPILOT Assist "suggests that itÂ’s an assistance feature, rather than a replacement for the driver." NHTSA and automakers say none of the systems make vehicles autonomous. Nissan said its name "is clearly communicating ProPILOT Assist as a system to aid the driver, and it requires hands-on operation.

Recharge Wrap-up: Chevy teases Bolt driving range, China pursues EV subsidy cheaters

Chevy is teasing the Bolt's driving range, which it is set to reveal on Tuesday. It will certainly be able to travel more than 200 miles between charges, but the second and third digits in that value, as it stands today, are still question marks. On its Facebook page, Chevrolet is asking fans to try to guess the official range. Of course, Tesla fans have already started posting their own snide remarks in the comments. Chevy fans are certainly hoping to see the Bolt's range eclipse that of Tesla's upcoming Model 3, which the California-based automaker puts at 215 miles. See Chevy's post on Facebook to make your own guess, or check back there (or here at AutoblogGreen) for the official number once it is unveiled. Fuel cell company PowerCell Sweden says it has signed an agreement with a Chinese company to make range extenders for commercial trucks. The unnamed Chinese customer has placed an order and signed a memorandum of understanding with PowerCell Sweden, and the partners will develop methanol reformer fuel cell range extenders for electric distribution trucks. "Our unique expertise in fuel cells and reformer technology is receiving an increasing attention worldwide and we are truly pleased to get another Chinese order," says PowerCell Sweden Sales Director Andreas Boden. Read more at Green Car Congress, or from PowerCell. China is accusing major automakers of violating EV subsidy rules. After the country's Ministry of Finance penalized five companies with fines and, in one case, revocation of production license for subsidy cheats, China has since named 20 more potential violators, including Nissan, Hyundai, JAC, and a subsidiary of BYD. Of the first five companies to be punished under the investigation, Suzhou Gemsea Coach Manufacturing is having its production license revoked, while four others, including a subsidiary of Chery, are being fined for about half of the subsidies received. The scandal is bad new for China's subsidy program, which has helped spur sales of plug-in vehicles. Read more from Fortune, or at Hybrid Cars.