2005 Chevrolet Cavalier Base Sedan 4-door 2.2l on 2040-cars

Auto blog

GM opens official investigation into C8 Corvette transmission leaks

In March 2020, a month after Chevrolet began customer deliveries of the 2020 C8 Corvette, a GM dealer technician created a Reddit thread about a leaking gearbox in a Corvette with 32 miles. That car hadn't even been sold yet. Since then, as a search of "C8 Corvette transmission leak" shows, it's been tales of woe for some owners. Something in the Tremec TR-9080 transaxle in the back of the mid-engined Corvette doesn't work as it should, the fault able to cause codes that the transmission needs service, or that the driver needs to shift to park. In some cases, the battery would die because of follow-on issues after the initial transmission code, that code preventing the car from powering down. As Autoevolution reports, GM filed paperwork with the National Highway Traffic Safety Administration in August to look into what's going on. Between forum threads and GM's investigation document, there are several issues mentioned. The most common appears to be the dual-clutch transmission leaking fluid due to gasket failures like the one suffered by one owner at 858 miles, and another for an owner currently enduring a second leaking transmission. The Midengined Corvette Forum reported that Chevy engineers redesigned the TR-9080 pan, fitting Corvettes with the new unit at some point in the 2021 model year. The original pan was stamped steel unit affixed to the engine with two studs and 13 bolts, plus "reinforcement plates." The updated pan is said to be a cast aluminum unit affixed with two studs and 17 bolts, omits the reinforcement plates, and gets a new machined new groove around its edge to seat the gasket seal. The GM paperwork now at the NHTSA mentions a P1789 code, and says one reason for it could be "debris on the park position sensor magnet causing an incorrect position reading to the TCM." This might be caused by another issue mentioned in forums, which is clogged transmission filters. GM gives instructions for returning transmission filters to the company, and a poster on one forum said the Corvette tech at the dealer where he bought his Corvette told him the automaker "requires every used transmission filter to be returned to GM."  Whatever's going on, the problems haven't stopped, and they go beyond the P1789 code. Over the weekend, a 2022 Corvette owner posted on Corvette Forums that he got a check engine light on his car after just 850 miles.

Two More Recalls Push GM Total To 4.8 Million In A Month

General Motors announced two more recalls late Friday, bringing to 4.8 million the number of cars, trucks and SUVs the automaker has called back for repairs in the past month. The string of recalls, topped by an ignition switch problem in compact cars now linked to 13 crash deaths, has embarrassed the company and sidetracked its new CEO, who started work just over two months ago. GM has admitted knowing about the switch problem a decade ago, yet it didn't recall any cars until February. The recall delay has brought two congressional investigations and probes by the Justice Department and the National Highway Traffic Safety Administration. Late Friday night, GM announced it would recall 490,000 late-model pickup trucks and SUVs because transmission oil cooling lines weren't secured properly in their fittings. Transmission oil can leak from a fitting and hit hot surfaces, causing fires, the company said in a statement. GM said it knows of three fires and no injuries. The recall affects Chevrolet Silverado and GMC Sierra 1500 pickup trucks from the 2014 model year, as well as 2015 Chevrolet Suburban and Tahoe SUVs and the GMC Yukon and Yukon XL SUVs. All have six-speed automatic transmissions. The Silverado is GM's top-selling vehicle and an important profit center for the company. The GMC Sierra also is among GM's top sellers. Dealers will inspect the transmission oil cooling line fittings and make sure they're securely seated, at no cost to owners. Also Friday night, GM announced the recall of 172,000 Chevrolet Cruze compact cars because the right front axle shaft can fracture and separate while being driven. The recall affects cars from the 2013 and 2014 model years equipped with 1.4-liter turbocharged four-cylinder gasoline engines. If a shaft fractures, the wheels would lose power without warning and the cars would coast to a stop. GM says it has warranty reports of several dozen shaft fractures. It is not aware of any crashes or injuries. Dealers will replace the shafts free of charge. The recall allows dealers to resume selling affected Cruzes. GM issued a stop sale order on the cars Thursday night. The recall also covers about 2,500 replacement shafts used to fix manual transmission Cruzes that were recalled last September. In all, GM has recalled 4.8 million vehicles since last month, two million more than the company sold last year in the U.S.

Mary Barra reportedly confirms GM's electric pickup truck plans

According to Motor Authority, CEO Mary Barra confirmed General Motors' intentions to build an electric pickup truck this week. Whether or not it would be an all-new vehicle is unknown. The news comes not even a week after Ford announced a $500 million investment in electric-vehicle startup Rivian. First, electric powertrains were integrated into cars. Then came the crossovers and the SUVs. Naturally, then, the next wave will be pickup trucks. Ford is set to produce an electric F-150, Rivian has the R1T, and now General Motors has reportedly confirmed its plans to introduce a competitor into the field. The article says the topic was brought up in a recent investor call as part of a brief overview of the automaker's electrification strategy. That's where the details end, however, as there is no indication of a timeline, what GM brand would carry the truck, or whether it would be an entirely new product or an adaptation of a current model. The latter seems most likely, which points to the Chevrolet Silverado or the GMC Sierra as possibilities. Chevrolet has been GM's electrification leader this decade with the Bolt and Volt, so an electric Silverado would align well with that messaging and branding. However, an electric pickup would likely be a pricier premium product, which could align it better with GMC. Autoblog has reached out to GM for comment and will update this space when we get a response. Green Rumormill Chevrolet GMC Truck Electric Future Vehicles Mary Barra electric truck chevrolet silverado