2002 Chevy Cavalier Blue 2-door on 2040-cars

Auto blog

GM might lose 90-year U.S. sales crown over chip shortage

Automotive News editor Nick Bunkley tweeted on October 1 that according to AutoNews data, General Motors "has been the largest seller of vehicles in the U.S. every year since passing Ford in 1931." With automakers having turned in light car and truck sales data for the first three quarters of 2021, GM's 90-year-run might not reach 91. According to AN figures, Toyota was 80,401 vehicles ahead when the October workday started. Worse, GM is so far behind its historic pace that it might only sell enough light vehicles in the U.S. to match its numbers from 1958.  Meanwhile, the New York Times put a few more salient numbers to the pain GM and Toyota are enduring alongside the the rest of the industry. GM sold 33% fewer cars in Q3 2021 than it did in Q3 2019 during the dark days of the pandemic, 446,997 units this year as opposed to 665,192 last year. GM's Q3 2020 was only down 13% on Q3 2019. Over at Toyota, the bottom line showed a 1% gain in Q3 2021 compared to 2020, with 566,005 units moved off dealer lots. The finer numbers show two steps forward and one step back, though; Toyota's September sales were down 22% compared to last year.  GM remains optimistic about what's ahead, GM's president of North American operations telling the NYT, "We look forward to a more stable operating environment through the fall." We'd like to see that happen, but we don't know how it happens. The chip shortage said to have been the inciting incident for the current woes isn't over, and not only can no one agree when it will be over, the automakers, chip producers, and U.S. government still can't get on the same page about who needs what and when. Looking away from that for a second shows articles about "No End In Sight" for supply chain disruptions in early September, before China had to start working through power supply constraints, global supply chain workers started warning of a "system collapse," and roughly 500,000 containers sat waiting to be unloaded at Southern California ports — a record number seemingly broken every week. And back to chips, we're told just a few days ago the chip shortage is "worse than we thought."   For now, the NYT wrote that GM dealer inventory is down 40% from June to roughly 129,000 vehicles, and down 84% from the days when dealers would cumulatively keep about 800,000 light vehicles in stock. However, GM just announced it would have almost all of its U.S. facilities back online next week, although some would run at partial capacity.

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

GM's labor deal with UAW union on verge of ratification

Nov 15 (Reuters) - General Motors' tentative labor deal with the United Auto Workers (UAW) union closed in on ratification as the votes were counted on Wednesday. Following the approval earlier in the day by more than 60% of union members at the Detroit automaker's large Arlington, Texas, assembly plant, additional votes in favor have the deal close to clinching majority approval. The number of union locals, most of which are smaller, still to report vote totals is not large. After several large assembly plants voted against the deal earlier on Wednesday, some media had reported the deal was heading toward failure. But Arlington's support, followed by strong voting in favor by smaller warehouse and parts facilities, has put the deal on the brink of approval. This would mark the first ratification of a deal, which runs through April 2028, with one of the Detroit Three automakers. Ford and Stellantis voting is still under way, and workers at both companies were favoring ratification by comfortable margins. The UAW's GM vote tracking site currently shows approval of the contract leading by a 54% to 46% margin with almost 32,000 workers having cast votes out of about 46,000 UAW-represented GM workers. The Arlington plant, with about 5,000 UAW members, has the most of any GM plant. Voting officially ends on Thursday at 4 p.m. EST, although most votes will be cast on Wednesday. The UAW went on strike for more than six weeks against the Detroit Three, seeking better wages, working conditions and cost-of-living adjustments. All three companies agreed to tentative agreements about two weeks ago. Workers at other GM assembly plants voted against the deal, including 60% of workers at its Fort Wayne, Indiana, truck plant, 53% at its Wentzville, Missouri, plant, 58% of workers at GM's Lansing Grand River plant and 61% of workers at the Lansing Delta Township plant. Seven of GM's 11 assembly plants rejected the deal. In addition to Arlington, workers at plants in Detroit, Fairfax, Kansas; and Lake Orion, Michigan; approved the agreement. Only nine facilities are still listed without vote totals on the UAW vote tracker, including GM's Lockport, New York, components plant with about 1,200 members. Those voting in favor of the agreement have a lead of almost 2,500 and many of the facilities still to come include workers who stand to receive large pay increases upon ratification.