82 Chevy Pickup Street Rod on 2040-cars

Auto blog

2016 Chevy Volt arrives with 50-mile EV range, 41 mpg [w/ video]

Let's start with the numbers. The 2016 Chevy Volt will have an all-electric range of 50 miles from a new, 18.4-kWh lithium battery. It will get 41 miles per gallon (combined) once the battery runs dry and have 102 MPGe. Oh, and it has five seats, sort of. To compare, today's four-seat 2015 Volt has a 38-mile range from a 17.1-kWh battery in a powertrain that offers 37 mpg and 98 MPGe. So, across the board, there are notable improvements. Now that that's out of the way, let's talk story. General Motors will unveil the new Volt at the Detroit Auto Show later today, but it's been talking about how this new version – the first major plug-in hybrid vehicle to get a serious redo in the modern era – was crafted with reams and reams of data from first-gen Volt customers. At a preview event for journalists last week, GM executive chief engineer Pam Fletcher told Autoblog that these owners "gave us the recipe" to make the second-gen model. At the top of the request list was more range (check), more "fun-to-drive" behavior (check?) and a smoother and quieter experience (we'll assume a check here, given that the new 1.5-liter four-cylinder – the first North American application of this new engine family – should offer more power with less noise than the previous 1.4-liter, four-cylinder powerplant). Other customer-driven changes in the new Volt include a different place to store the charging cable (in the side of the trunk instead of under the load floor) and a new brake system with improved blended regenerative braking feel as well as driver-selectable regen levels. The requested 50-mile range comes from a new, lighter battery that has increased capacity from fewer cells (192 vs. 288) and a simplified control architecture. Along with the new battery, the electric drive unit is a two-motor deal that is up to 12 percent more efficient and 100 pounds lighter, while also being "tremendously smaller," notes Fletcher. It offers 294 pound-feet of torque and a maximum 149 horsepower of "motoring power" delivered to the wheels. GM says it has worked hard to reduced the amount of rare earth materials in these motors, and one of them doesn't use any at all. The new powertrain offers improved acceleration times, as well. The 2016 Volt can go from 0 to 60 miles per hour in 8.4 seconds, a seven-percent improvement, while the 0-30 mph time has been improved by 19 percent, down to 2.6 seconds. The new Volt is more conventional looking, but certainly not completely ordinary.

GM under fire from safety advocates over braking problem caused by recall fix

Safety experts are lambasting General Motors over what they say is the automaker’s slow notification of owners of certain 2019 sedans and trucks that a recall fix could cause power braking to fail and increase the risk of a crash, the Detroit Free Press reports.  GMÂ’s original recall in December targeted about 550,000 Cadillac CT6 sedans and Chevrolet Silverado 1500 and GMC Sierra 1500 pickups, all from the 2019 model year, over potentially defective electronic stability control and antilock brakes. In that case, GM said the errors would not show up as a diagnostic warning on the instrument cluster. But after GM had done recall work on 162,000 vehicles, about 1,700 owner have complained that their power brakes didnÂ’t work after they had the recall done and then used the OnStar app to start their vehicle. GM then issued a supplemental fix for customers whoÂ’d already had their vehicles serviced. In this case, a diagnostic warning should illuminate saying either “Service Brake Assist” or “Service ECS,” which GM says is a signal that a customer should not drive the vehicle and instead call their dealer, which will tow the vehicle and have it repaired. Safety advocates say the automaker hasnÂ’t gone far enough to protect customers. “The fact that you could potentially start a vehicle and not have brakes is a pretty risky proposition,” Sean Kane, president of the Safety Research and Strategies, which works on auto issues for plaintiffs and governmental organizations, told the Freep. “The fact that they wouldnÂ’t notify owners (sooner) is pretty stunning.” GM told the Freep it was required to notify the National Highway Traffic Safety Administration and file paperwork before it notified customers about the original recall, which was made Dec. 12. It then had to investigate and resolve the problem created by its original recall fix before alerting customers. GMÂ’s call center and dealers are contacting the remaining 900 customers who havenÂ’t yet had the update made to the original recall repair. GM also hired a vendor to send recall letters to the 550,000 customers affected by the original recall notifying them about the update. There are no known injuries or deaths related to the problem. Read the Freep story here.

Recharge Wrap-up: BYD unveils 60-ft electric bus, Honda sticking with hybrids in Europe

BYD has debuted a 60-foot electric bus at the American Public Transportation Association Expo in Houston, TX. The Lancaster bus, as it is called, has a 120-passenger capacity and can drive over 170 miles on a single charge. The articulated bus features low floors and no steps, thanks to in-wheel hub motors. BYD also displayed a 40-foot electric bus that drove the 1,500 miles to the show under its own power (recharging along the way, of course). Read more in the press release below. Honda says it will continue to sell hybrids in Europe, despite the fact that it has stopped selling the CR-Z and Insight due to slow sales. "Our focus at the moment is on our 1.6-liter diesel but we haven't forgotten about hybrid technology," says Honda Europe's Philip Ross. Honda will sell the next-generation Fit (badged as the Jazz) in Europe when it launches next summer, and will sell the next-gen hybrid version beginning in 2016. Honda sold 4,500 of the Jazz hybrid in Europe last year. Read more at Automotive News. XL Hybrids is selling its XL3 Hybrid Electric Drive System in California. The news comes after the California Air Resources Board issued an executive order allowing the aftermarket hybrid conversion for 2012-2014 Chevrolet Express and GMC Savana vans. The XL3 Hybrid regenerative braking conversion increases real-world mpg by about 25 percent. Read more in the press release below. NRG eVgo has finished installing 60 charging stations at the Sony Pictures Entertainment studio lot and offices in Culver City, California. The Level 2 chargers, which will be managed by NRG eVgo, allow employees to charge their EVs during the workday. An average of 90 EVs and PHEVs park at the studio headquarters every day, thanks in part to Sony Pictures' Alternative Vehicles Incentive program for its employees. Learn more in the press release below. Pennsylvania's Public Utility Commission will allow operators of EV charging stations to set prices based on kilowatt hour usage. This change ensures that drivers pay for the actual energy they use, rather than the time they spend charging, since different cars can charge at different speeds. Car Charging Group has already begun using the per-kWh fee structure at its charging stations throughout the state. Other states that allow kWh pricing are California, Colorado, Florida, Hawaii, Illinois, Maryland, Minnesota, New York, Oregon, Virginia and Washington. Read more in the press release below.