2009 Bmw X5 Xdrive48i on 2040-cars

Auto blog

BMW crushing ActiveE EVs, saving all batteries

It's unlikely to spark a movement and a movie, the way a certain EV1 did a decade ago, but anyone who's seen Who Killed The Electric Car? will likely cringe at this bit of news. Despite the fact that crushing and recycling old vehicles is standard operating procedure in the auto industry, when EVs are involved, it's always a touchy subject. The next phase will see "all of the lithium-ion batteries being repurposed for Battery Second Life research projects." So, what's the news? Well, the image you see above, which comes from the spotting of 16 smashed BMW ActiveE EVs on flatbed trailers on California Route 91 near Los Angeles, CA. EV advocate Chelsea Sexton told Green Car Reports, "It's all very deja vu, right down to [BMW's] DriveNow promotion as a don't-look-behind-the-curtain distraction – recall GM touting EV1s being donated to museums and universities? – and VINs spray painted on the sides, allowing former drivers to identify their own cars." BMW's take on this is that the ActiveEs were always meant to have a limited lifespan, and their time has come. As spokesman Dave Buchko tells AutoblogGreen, "The learning begun with the ActiveE will transition to the next phase with all of the lithium-ion batteries being repurposed for Battery Second Life research projects." (You can read his full statement below.) Originally, there were 700 ActiveEs leased to Electronauts (give or take). Yahoo! Autos points out that the ActiveEs were originally imported into the US as "pre-production" cars, which means they can't be sold, they can only be used for carsharing projects or re-leased. Eighty of those ActiveEs recently found a second life as vehicles in BMW's DriveNow carsharing fleet in San Francisco (bringing the total of ActiveEs in the program to 150) and "some have also been returned to Munich for additional research markets," Buchko said. The big picture here is that no one should be sad to see these cars go. Yes, they may have had some life left in them, but the rules say their time is done and everything is being done to crush responsibly in accordance with the law. Like Plug In Cars says, we're in a completely different era now than we were when GM crushed all those EV1s a decade ago. Instead of marking the end of a plug-in vehicle program, sending the ActiveEs away to be recycled is a symbol of the evolution and growth of BMW's i Project.

As BMW i3 US launch nears, more details discovered

Think of the BMW i3's gas-powered range-extender as akin to driving around with a middle linebacker in the back seat. Except that football player will have a hard time pushing the car 60 miles or so once the battery runs out. Thankfully, he won't prevent you from getting a nifty tax credit either, according to BMWBlog, which isn't affiliated with the company. The i3's front storage compartment is not watertight. Here in the US, where the i3 will be available in short order, BMW will offer an optional i3 plug-in vehicle with a range extender that will have a 1.9-gallon capacity gas tank. That sounds a good deal smaller than the 2.4-gallon tank used in Europe, but the two are actually the same, the US tank is simply limited to the smaller size, Dave Buchko, from BMW's product and technology communications department, told AutoblogGreen. The complete range extender system – including the tank, the engine, and all related hardware – adds about 265 pounds to the 2,634-pound curb weight of the i3 EV and the extra weight in turn adds about a second to the EV's 0-to-60 time of seven seconds flat. Adding the range-extender won't make the US government take any longer to dole out a $7,500 tax credit for the i3, though. We also learned that the i3's front storage compartment is not watertight since it is only meant to hold the mobility kit and the 110-volt charging cord. BMW recently increased its production of the i3 at its German factory from around 70 units a day to about 100 due to better-than-expected demand. Check out our First Drive impressions of the model here.

Recharge Wrap-up: BMW plans for retired batteries; automakers support dual-standard chargers

Toyota will test hybrids with silicon-carbide (SiC) power semiconductors. In Japan, Toyota has put the SiC power semiconductors into the power control units of a Camry Hybrid prototype and a fuel cell bus for a year-long test. Research suggests the SiC units will decrease electrical losses while managing power supply, thus improving overall powertrain efficiency. Current power semiconductors account for about 20 percent of electrical losses, and success with these tests could mean more efficient hybrids on the roads in the future. Read more at Hybrid Cars. Automakers from CCS and CHAdeMO camps are supporting dual-standard charging station networks. https://www.autoblog.com/bmw/, Volkswagen (CCS camp) and ChargePoint announced plans to build "express charging corridors" by installing about 100 DC fast chargers, many of which will support both types of charging. Kansas City Power & Light is partnering with Nissan (CHAdeMO camp) and ChargePoint to install DC chargers that "will charge any model of electric vehicle on the market." This leads the folks at Green Car Reports to look into whether this ends the looming standard war between automakers in the US. Read more at Green Car Reports. BMW, Bosch and utility company Vattenfall are making plans for a second life for retired BMW i3 batteries. The Second Life Batteries Alliance project will recycle the old lithium ion battery packs - which can still hold a charge - in off-grid storage and grid-stabilization applications, beginning with a grid storage system in Hamburg, Germany. Bosch has created a battery management algorithm to extend the life of the batteries and make sure they don't cause harm to Vattenfall's facilities. Read more at Transport Evolved.