2014 Volkswagen Tiguan S on 2040-cars

Auto blog

Crash test videos show how rust compromises safety

These recently released Swedish videos serve as a reminder that rust isn't just a cosmetic flaw, when it comes to cars. The insurance company Folksam and the homeowner organization Villaagarnas Riksforbund gathered examples of two relatively popular, but by now rusty cars, and then performed crash tests with them at the Thatcham Research facility in Britain. The results are sobering. The rustier cars chosen for the tests were first-generation Mazda6s, cars that have a reputation for early-onset rust in salty surroundings, such as the Nordic countries in Europe or the Salt Belt in the U.S. The cars in the other end of the spectrum were fifth-generation Volkswagen Golfs, which thanks to their body treatment only really start to show rust at over ten years old. But rust isn't just on the surface, it goes bone deep. While the Mazda did decently well in Euro NCAP testing as a new car, there's now a 20 percent higher risk of death in the 2003-2008 Mazda due to the degradation of its bodyshell. In the rusty car, the chassis rail separates from the floor, the footwell ruptures, the sill gives way, the seat mountings move and the dummy's head hits the B-pillar; all important failures, despite Thatcham saying the cars actually performed better in the crashes than they expected with all the rust. But still, the corroded structure isn't able to transmit loads in the way it was originally designed to do. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. The Golf does significantly better — despite rust flakes flying when the Golf hits the wall — as the years have only caused it to lose a single point. An important thing to remember is that the cars aren't tested in comparison to corresponding new, 2018 cars: the tests are in reference to the crashworthiness standards in place when they were new. The cars' airbags inflate like they were supposed to, but on the Mazda the dummy's head bottoms out the airbag due to the car's structure failing, meaning the airbag cannot perform as designed. Driven cautiously, an older car is still mostly fine for driving around. But tests like these remind us that it's not enough that a car runs and drives, if the body has turned into Swedish knackebrod. And if you repair the visible rust and the structure underneath remains as compromised as ever, there's an ugly truth under all the bondo. Perhaps it isn't such a bad idea to have yearly roadworthiness inspections.

Only VW, Volvo are doing enough to electrify in Europe, study says

Among major carmakers, Volkswagen and Volvo are doing enough to electrify their vehicle lineups in Europe, and the EU needs to set tougher CO2 emission limits if it wants to meet Green Deal targets, according to a climate group's study. Sales of battery electric vehicles and plug-in hybrids almost tripled last year, boosted by tighter emission standards and government subsidies. This summer, the European Union is expected to announce more ambitious CO2 targets; by 2030, the average CO2 emissions of new cars should be 50% below 2021 levels, versus the existing target of 37.5%. Volkswagen aims to have 55% group-wide BEV sales in Europe by 2030, while Swedish carmaker Volvo, owned by China's Geely says its lineup will be fully electric by then. VW ID4 front three quarter dark View 19 Photos Based on IHS Markit car production forecasts, according to the study from European campaign group Transport and Environment (T&E), Volkswagen and Volvo have "aggressive and credible strategies" to shift from fossil-fuel cars to electric vehicles. Others like Ford Motor Co have set ambitious targets, "but lack a robust plan to get there," T&E said. Ford plans an all-electric lineup in Europe by 2030. T&E said BMW, Jaguar Land Rover (JLR), Daimler AG and Toyota rank the worst as they have low BEV sales, have "no ambitious phase-out targets, no clear industrial strategy, and an over-reliance in the case of BMW, Daimler and Toyota on hybrids." JLR, owned by India's Tata Motors, says its luxury Jaguar brand will be all-electric by 2025, but has been less specific about electrification of its higher-volume Land Rover brand. BMW and Daimler have been reluctant to set hard deadlines for phasing out fossil-fuel cars. T&E said even if carmakers meet their targets, in 2030 BEV sales could be 10 percentage points below those needed to meet the EU's Green Deal — which targets net zero emissions by 2050. Rather than a 50% reduction in CO2 emissions by 2030, based on carmakers' existing production plans, the EU could set more ambitious targets, T&E said - an up to 35% reduction in CO2 emissions from new cars by 2025, around 50% by 2027 and up to 70% in 2030. "Targets need to be gradually tightened so that carmakers not only commit to phasing out fossil fuels, but develop a strategy that gets them there on time," Julia Poliscanova, T&E senior director for vehicles and e-mobility, said in a statement.

Volkswagen names new chief designer for Bentley

The Volkswagen Group has named one of its own to head up the design department at its Bentley division. The role now falls to Stefan Sielaff, who has been with the group (off and on) since 1990. Sielaff is principally an interior designer, but has been tasked with setting up numerous overall design offices for Volkswagen and Audi over the years. In his new capacity he'll be reporting to the group's chief engineer Rolf Frech (and oddly not to Bentley chief Wolfgang Durheimer), but at the same time, Sielaff will retain his role as head of interior design for the entire VW group, reporting to its chief designer Walter de Silva. Sielaff replaces Luc Donckerwolke, who has headed up Bentley design since 2012 and is leaving the company. We'll be on the lookout to see where Donckerwolke lands next. Crewe/Wolfsburg, 04 June 2015 Stefan Sielaff to head design at the Bentley brand • Sielaff also responsible for Group Interior Design Strategy Stefan Sielaff (53), currently Head of the Volkswagen Design Center in Potsdam, will assume responsibility for design at the Bentley brand effective July 1, 2015 in addition to his present post as Head of Group Interior Design Strategy. As Director of Design at Bentley, Sielaff succeeds Luc Donckerwolke (49), who held this function since 2012. Stefan Sielaff joined the Volkswagen Group in 1990, beginning his career in the interior design department at Audi. From 1995 the design graduate was entrusted with setting up the Group's Design Center Europe in Spain. In 1997 he was placed in charge of the Design Studio in Munich and was appointed Head of Audi Interior Design in the same year. In 2003 Sielaff moved to DaimlerChrysler as Design Director of the Interior Competence Center, returning to the Volkswagen Group in 2006 to become Head of Audi Design before being appointed Head of the Volkswagen Design Center in Potsdam und Head of Group Interior Design Strategy in 2012. In his new function as Director of Design at Bentley, Sielaff reports to Rolf Frech, Board Member for Engineering. In his function as Head of Group Interior Design Strategy he continues to report to Walter de Silva, Head of Group Design. Luc Donckerwolke has decided to leave the company. De Silva said: "Luc Donckerwolke has played a key role in the design of various Group brands. We would like to thank him for his work." Related Video: News Source: Volkswagen Design/Style Hirings/Firings/Layoffs Bentley Volkswagen