1971 Volkswagen Squareback on 2040-cars

Auto blog

VW recalls 220,000 Atlases, Atlas Cross Sports for airbag defect [Updated]

[Update: Audi of America has confirmed that no U.S. models are among the recall population for plug-in hybrid fire issue.] Volkswagen has issued yet another recall for its Atlas SUV, this time for side airbags that may not deploy correctly in an accident due to a problematic connection in one of the vehicle's wiring harnesses. The campaign covers 222,892 Atlas and Atlas Cross Sport models built for the 2019-2023 model years.  The issue stems from a connection with the wiring harness that runs from the A-pillar into the door. VW says that harnesses produced by one of its suppliers were not built with additional measures to prevent movement at the connection point. Small movements can cause abrasion of the metal contacts which could lead to a whole host of electronic misadventures, including the potential for airbag deployment to be delayed in a crash.  "Micro-movement of the wire harness (terminal A-Pillar to front door) can result in damage to the wire terminal surface. Damage to the surface can [result] in fretting corrosion which may cause sporadic interruption in the electrical connection to the components of the front door," VW said in its defect notice. "The airbag warning light may illuminate if a malfunction is detected. Other symptoms of a sporadic interruption of the affected electrical connection can be: inadvertent rolling down windows, inadvertent park brake engagement at low speeds (below approx. 3km/h or 1.8mph), warning regarding faulty door sensor," VW said.  Not every model built within the range defined above is subject to the recall; terminals from other suppliers were manufactured with the necessary safeguards in place. If you own a 2019-2023 Atlas or Atlas Cross Sport, keep your eyes peeled for a notification from VW regarding the campaign, likely some time in early-mid May.  PHEV problems Across the Atlantic, the VW Group mothership confirmed that it will recall more than 100,000 plug-in hybrid models worldwide to address a fire risk. The recall was launched in response to 16 reported incidents of fires stemming from insufficient insulation of the PHEV battery pack that allows the engine cover to make contact if it is not completely secure. If that happens, the heat from the battery can ignite the engine cover. The recall will cover PHEVs build by VW, Audi, Seat and Skoda, Reuters reports, including the VW Passat, Golf, Tiguan and Arteon — plug-in variants of which are not sold in the United States.

Brand new cars are being sold with defective Takata airbags

If you just bought a 2016 Audi TT, 2017 Audi R8, 2016–17 Mitsubishi i-MiEV, or 2016 Volkswagen CC, we have some unsettling news for you. A report provided to a US Senate committee that oversees the US National Highway Traffic Safety Administration (NHTSA) and reported on by Automotive News claims these vehicles were sold with defective Takata airbags. And it gets worse. Toyota and FCA are called out in the report for continuing to build vehicles that will need to be recalled down the line for the same issue. That's not all. The report also states that of the airbags that have been replaced already in the Takata recall campaign, 2.1 million will need to eventually be replaced again. They don't have the drying agent that prevents the degradation of the ammonium nitrate, which can lead to explosions that can destroy the airbag housing and propel metal fragments at occupants. So these airbags are out there already. We're not done yet. There's also a stockpile of about 580,000 airbags waiting to be installed in cars coming in to have their defective airbags replaced. These 580k airbags also don't have the drying agent. They'll need to be replaced down the road, too. A new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time. If all this has you spinning around in a frustrated, agitated mess, there's a silver lining that is better than it sounds. So take a breath, run your fingers through your hair, and read on. Our best evidence right now demonstrates that defective Takata airbags – those without the drying agent that prevents humidity from degrading the ammonium nitrate propellant – aren't dangerous yet. It takes a long period of time combined with high humidity for them to reach the point where they can rupture their housing and cause serious injury. It's a matter of years, not days. So a new vehicle with a defective Takata airbag should be safe to drive, but that margin of safety decreases with time – and six years seems to be about as early as the degradation happens in the worst possible scenario. All this is small comfort for the millions of people who just realized their brand-new car has a time bomb installed in the wheel or dashboard, or the owners who waited patiently to have their airbags replaced only to discover that the new airbag is probably defective in the same way (although newer and safer!) as the old one.

2016 VW diesels are still 'months' out

Many 2016 model year vehicles are already for sale at dealers in the US but none of them have Volkswagen's 2.0-liter TDI. Don't expect to see the diesels on lots for several months either. The Environmental Protection Agency is preparing an onslaught of evaluations on the engine to make sure that it doesn't get fooled again, Automotive News reports. Before the new tests can even begin, VW must resubmit the 2016 diesels to the EPA, and the company isn't saying when that might be. The automaker took back the models' previous application after telling the EPA about an undisclosed software feature, according to Automotive News. There was absolutely no evidence that this was another defeat device, but the emissions agency wanted more information about what the tech's effect was. EPA boss Christopher Grundler has been quite clear about not disclosing any details about the new tests. He doesn't want to give automakers a chance to create more defeat devices, and the agency intends to evaluate diesels from other companies with more rigor, too. That process is already beginning in cases like subjecting the 2016 Chevrolet Colorado Duramax to on-road emissions checks. Once the 2016 VW models are certified, the EPA intends to run the same tests on the proposed repairs for the company's earlier diesels. That process could take months, as well, according to Automotive News. VW CEO Matthias Muller recently said that the first recalls likely wouldn't happen until January.