2012 Volkswagen Gli 4dr Sdn Autobahn One Owner, 23k Miles on 2040-cars

Auto blog

BMW, Ferrari, VW cars use tungsten mined by terrorists

Bloomberg Markets is reporting that BMW, Volkswagen and Ferrari have been using tungsten ore sourced from Columbia's FARC rebel terrorists. The extensive story focuses on Columbia's illegal mining trade and calls into question the provenance of the rare ore that is used not only in crankshaft parts production, but is also found in the world's computing and telecommunications industry for use in screens.
The ore is mined by the FARC (Fuerzas Armadas Revolucionarias de Colombia, or Revolutionary Armed Forces of Colombia - People's Army), and exported to Pennsylvania, where it is refined. The refined ore is then sent over to Austria, where a company called Plansee turns it into a finished product. Now, it's important to note that we aren't talking about the world's supply of tungsten here. In 2012, Plansee's American refinery purchased 93.2 metric tons of tungsten, valued at $1.8 million. That's peanuts, with the entire Colombian tungsten mining industry producing just one percent of the world's supplies.
That doesn't make indirectly supporting FARC any more acceptable, though. BMW, VW and Ferrari are all committed to not accepting mineral supplies from the Democratic Republic of Congo, which is also in the grips of a guerrilla insurrection funded, in part, by illegal mining. The same commitment would figure to extend to Colombian mining, but as BMW points out, it's difficult for a multi-national manufacturer to know where every item in its supply chain comes from. A company spokesperson says as much, telling Bloomberg, "These few grams out of the billions of tons of raw materials passing through the BMW supply chain are of no practical relevance."

VW recalls 220,000 Atlases, Atlas Cross Sports for airbag defect [Updated]

[Update: Audi of America has confirmed that no U.S. models are among the recall population for plug-in hybrid fire issue.] Volkswagen has issued yet another recall for its Atlas SUV, this time for side airbags that may not deploy correctly in an accident due to a problematic connection in one of the vehicle's wiring harnesses. The campaign covers 222,892 Atlas and Atlas Cross Sport models built for the 2019-2023 model years.  The issue stems from a connection with the wiring harness that runs from the A-pillar into the door. VW says that harnesses produced by one of its suppliers were not built with additional measures to prevent movement at the connection point. Small movements can cause abrasion of the metal contacts which could lead to a whole host of electronic misadventures, including the potential for airbag deployment to be delayed in a crash.  "Micro-movement of the wire harness (terminal A-Pillar to front door) can result in damage to the wire terminal surface. Damage to the surface can [result] in fretting corrosion which may cause sporadic interruption in the electrical connection to the components of the front door," VW said in its defect notice. "The airbag warning light may illuminate if a malfunction is detected. Other symptoms of a sporadic interruption of the affected electrical connection can be: inadvertent rolling down windows, inadvertent park brake engagement at low speeds (below approx. 3km/h or 1.8mph), warning regarding faulty door sensor," VW said.  Not every model built within the range defined above is subject to the recall; terminals from other suppliers were manufactured with the necessary safeguards in place. If you own a 2019-2023 Atlas or Atlas Cross Sport, keep your eyes peeled for a notification from VW regarding the campaign, likely some time in early-mid May.  PHEV problems Across the Atlantic, the VW Group mothership confirmed that it will recall more than 100,000 plug-in hybrid models worldwide to address a fire risk. The recall was launched in response to 16 reported incidents of fires stemming from insufficient insulation of the PHEV battery pack that allows the engine cover to make contact if it is not completely secure. If that happens, the heat from the battery can ignite the engine cover. The recall will cover PHEVs build by VW, Audi, Seat and Skoda, Reuters reports, including the VW Passat, Golf, Tiguan and Arteon — plug-in variants of which are not sold in the United States.

10 automakers sued over keyless ignitions

Keyless ignition has rapidly proliferated throughout the auto industry to become a fairly normal feature on new cars. It's supposed to offer the convenience of keeping the fob in your pocket and just pressing a button to drive away. However, ten major automakers are now being sued in US District Court over claims that the system is dangerous, Reuters reports. The suit alleges that people are forgetting to shut off the engine, and the lack of an idle timer is the cause for 13 deaths by carbon monoxide poisoning and multiple injuries. The suit currently includes 28 plaintiffs, according to Reuters, but the lawyers are asking for class-action status to potentially add many more. The case goes after a major swath of the industry, including BMW, Daimler, FCA, Ford, General Motors, Honda, Hyundai, Nissan, Toyota, and Volkswagen, plus their related brands like Acura, Infiniti, Mini, and Lexus. In all, over five million vehicles are affected. The assertion here is that people walk away from their vehicle without shutting it off because they believe the engine shuts off automatically. If parked in a garage, carbon monoxide can build up, leading to poisoning. The lawyers claim automakers know this is a problem and also cite 27 complaints to the National Highway Traffic Safety Administration about the issue, according to Reuters. The plaintiffs are asking for an automatic shut-off and damages from the companies. These concerns have come up before, though. Toyota previously faced a lawsuit over a carbon monoxide death after a woman accidentally left her Lexus running. Also earlier this year, GM recalled 64,186 examples of the 2011-2013 Chevrolet Volt because owners weren't shutting them off. The problem resulted in two injuries, and the company released a software update to limit the idling time.