2007 Volkswagen Jetta Wolfsburg Edition on 2040-cars

Auto blog

Crash test videos show how rust compromises safety

These recently released Swedish videos serve as a reminder that rust isn't just a cosmetic flaw, when it comes to cars. The insurance company Folksam and the homeowner organization Villaagarnas Riksforbund gathered examples of two relatively popular, but by now rusty cars, and then performed crash tests with them at the Thatcham Research facility in Britain. The results are sobering. The rustier cars chosen for the tests were first-generation Mazda6s, cars that have a reputation for early-onset rust in salty surroundings, such as the Nordic countries in Europe or the Salt Belt in the U.S. The cars in the other end of the spectrum were fifth-generation Volkswagen Golfs, which thanks to their body treatment only really start to show rust at over ten years old. But rust isn't just on the surface, it goes bone deep. While the Mazda did decently well in Euro NCAP testing as a new car, there's now a 20 percent higher risk of death in the 2003-2008 Mazda due to the degradation of its bodyshell. In the rusty car, the chassis rail separates from the floor, the footwell ruptures, the sill gives way, the seat mountings move and the dummy's head hits the B-pillar; all important failures, despite Thatcham saying the cars actually performed better in the crashes than they expected with all the rust. But still, the corroded structure isn't able to transmit loads in the way it was originally designed to do. This content is hosted by a third party. To view it, please update your privacy preferences. Manage Settings. The Golf does significantly better — despite rust flakes flying when the Golf hits the wall — as the years have only caused it to lose a single point. An important thing to remember is that the cars aren't tested in comparison to corresponding new, 2018 cars: the tests are in reference to the crashworthiness standards in place when they were new. The cars' airbags inflate like they were supposed to, but on the Mazda the dummy's head bottoms out the airbag due to the car's structure failing, meaning the airbag cannot perform as designed. Driven cautiously, an older car is still mostly fine for driving around. But tests like these remind us that it's not enough that a car runs and drives, if the body has turned into Swedish knackebrod. And if you repair the visible rust and the structure underneath remains as compromised as ever, there's an ugly truth under all the bondo. Perhaps it isn't such a bad idea to have yearly roadworthiness inspections.

Chrysler and Fiat offering $1,000 rebates to VW owners as Marchionne gets tough

The throw-down between Fiat CEO Sergio Marchionne and Volkswagen has heated up in earnest. According to Bloomberg, Fiat and Chrysler are now offering current Volkswagen owners in the US $1,000 rebates to trade in their ride. It's the latest in a series of shots Marchionne has taken at his German rival. As you may recall, the Fiat executive entered into a spat with Volkwagen board chairman Ferdinand Piëch and CEO Martin Winterkorn in October after the duo called for Marchionne's resignation from presidency of the European Automotive Manufacturers Association (AECA). At the time, the Volkswagen executives were quoted as saying Fiat would not survive the European economic downturn.
In response, Marchionne called the German executives "reprehensible," and accused Volkswagen of using a pricing strategy that has created created a "bloodbath" in the EU. Volkswagen has taken to steep discounting to carve out ever-larger slices of market share in Europe, but the company has a much smaller foothold in the US. Marchionne may be trying to hit Volkswagen where the manufacturer is weakest with the new Fiat new incentive program.
Late last week, the Fiat executive was voted to a second term as ACEA president.

VW fix would have cost $335 per vehicle

Since the Volkswagen diesel kerfuffle began, Bosch, the world's largest auto supplier, has been hooked up to a bullhorn trying to make sure everyone knows its side of the story. Bosch supplied VW with the engine management testing software, including delivery and metering modules, that VW then used to skirt emissions laws in the US. Bosch told VW in 2007 that it was illegal to use the software in cars it planned to sell yet VW did it anyway, according to reports coming out in German newspapers Bild am Sonntag and Frankfurter Allgemeine Zeitung. That first warning came two years after VW started developing the small-displacement diesel, around the time that the two men pushing its development, then-brand chief Wolfgang Bernhard and engineer Rudolf Krebs, were telling their superiors that the engine needed AdBlue urea injection to pass US emissions. VW cost controllers wouldn't approve the AdBlue solution because it would add 300 euros ($335 US) to the cost of the vehicle. Bernhard and Krebs left the same year that Bosch advised VW about the software, two years before the engine went into production. That's when things get cloudy. A report in Automotive News says that when Martin Winterkorn took over in 2007 as head of the VW Group and brand, he asked Ulrich Hackenberg and Wolfgang Hatz to keep working on the engine, and "[the] engine then ended up in VW Group diesels" with that problematic software still intact. No one has yet pointed any fingers at this latter chain of command, but like a game of Clue, right now they're the professors in the library holding the candlesticks. Warnings didn't only come from the supplier: Frankfurter says VW's initial investigation has found that an engineer issued the same caution to the company in 2011. Neither Bosch nor VW would comment on the reports.