1973 Volkswagen Super Beetle Base 1.6l on 2040-cars

Auto blog

West Virginia researcher describes how Volkswagen got caught

The cheating scandal engulfing the world's largest automaker started with a road trip. In the spring of 2014, researchers from West Virginia were evaluating the tailpipe emissions of diesel cars made for the American market by European manufacturers, something never before studied in the academic realm. Excited by the prospect of breaking new ground, the team of two professors and two students wanted to gather as much data as possible. "And being academics, we went a little overboard," said Arvind Thiruvengadam, one of the students. "Being academics, we went a little overboard." Overboard included driving the cars for more miles than they needed to test and verify results. Drivers put about 1,500 miles on each of the first two cars in the study, a Volkswagen Jetta and BMW X5, along California roadways. For their final car, a Volkswagen Passat, they wanted even more mileage. So they took the car on a road trip from Los Angeles to Seattle and back again, collecting data from more than 2,000 miles of testing. The road trip was Volkswagen's undoing. When the West Virginia team returned to Los Angeles, they were befuddled by the test results. In theory, the Passat should have spewed the lowest levels of pollutants among the three cars. Equipped with the more modern selective catalytic reduction technology, the team expected to find minimal levels of nitrogen oxide. But the car, which had been certified at a California Air Resources Board facility prior to the start of the road trip, had elevated levels of NOx that were 20 times the baseline levels established beforehand. The researchers, comprised of professors Gregory Thompson and Dan Carder and students Marc Besch and Thiruvengadam, knew their on-board equipment functioned properly because, early in their research, they had double-checked its accuracy after recording sky-high NOx readings from the Jetta that showed 30 times the level of its baseline testing at the CARB facility. It was particularly noteworthy because the Jetta contained the first-generation Lean NOx Trap technology, not the more efficient SCR, yet both produced large discrepancies. The BMW, on the other hand, performed as expected. Today, Thiruvengadam is careful to say the research team never suspected Volkswagen of cheating on emissions testing, nor did the researchers report such a finding. They merely reported their findings to CARB officials who then further investigated.

Volkswagen could build plug-in hybrids in China

When you're Europe's largest automaker and your largest global market happens to be the one most notorious for its pollution (China), some solutions just present themselves. Volkswagen may be heeding that call. During the upcoming Beijing Motor Show, the company is expected to announce plans to produce plug-in hybrid electric vehicles in China, Reuters says, citing sources within the company. Few details have emerged, though the plug-ins will likely be produced at VW's Foshan factory in South China, which currently makes the Golf and Audi A3 and has plans to eventually make 600,000 vehicles annually. News has been percolating for a while, as Oliver Schmidt, general manager engineering and environmental office for Volkswagen Group of America, said last March that the company was planning at least two plug-in hybrid lines under the VW badge (and another three with its Audi and Porsche affiliates), including possibly a Touareg and Jetta PHEV. VW said late last month that it was looking to speed up development of "particularly eco-friendly models" made by Shanghai Volkswagen as well as developing a "new, very eco-friendly vehicle" with First Automotive Works (FAW). Earlier this year, VW unveiled its Golf GTE plug-in hybrid at the Geneva Motor Show. That model has a 1.4-liter turbocharged four-cylinder engine and an electric motor to provide 201 horsepower and 258 pound-feet of torque. The car can travel as many as 81 miles on electric power alone.

BMW, Ferrari, VW cars use tungsten mined by terrorists

Bloomberg Markets is reporting that BMW, Volkswagen and Ferrari have been using tungsten ore sourced from Columbia's FARC rebel terrorists. The extensive story focuses on Columbia's illegal mining trade and calls into question the provenance of the rare ore that is used not only in crankshaft parts production, but is also found in the world's computing and telecommunications industry for use in screens.
The ore is mined by the FARC (Fuerzas Armadas Revolucionarias de Colombia, or Revolutionary Armed Forces of Colombia - People's Army), and exported to Pennsylvania, where it is refined. The refined ore is then sent over to Austria, where a company called Plansee turns it into a finished product. Now, it's important to note that we aren't talking about the world's supply of tungsten here. In 2012, Plansee's American refinery purchased 93.2 metric tons of tungsten, valued at $1.8 million. That's peanuts, with the entire Colombian tungsten mining industry producing just one percent of the world's supplies.
That doesn't make indirectly supporting FARC any more acceptable, though. BMW, VW and Ferrari are all committed to not accepting mineral supplies from the Democratic Republic of Congo, which is also in the grips of a guerrilla insurrection funded, in part, by illegal mining. The same commitment would figure to extend to Colombian mining, but as BMW points out, it's difficult for a multi-national manufacturer to know where every item in its supply chain comes from. A company spokesperson says as much, telling Bloomberg, "These few grams out of the billions of tons of raw materials passing through the BMW supply chain are of no practical relevance."