1973 Volkswagen Beetle, on 2040-cars

Auto blog

An inside look at VW's new California R&D center

Less than two months ago, the Volkswagen Group opened a new facility in Oxnard, California (about an hour's drive west of Los Angeles). The $27 million investment, touted as Test Center California (TCC), serves as a research and development lab testing emissions for all brands under Volkswagen's umbrella, including its newest member, Porsche. While still not fully operational, we toured the new 64,000-square-foot building last week and had a first-hand opportunity to see just how much work is involved testing engines and meeting increasingly stringent government emissions standards.
Replacing a similar facility established in 1990 in Westlake Village (about 20-minutes east of the new location), our guide explained how Oxnard was chosen for its temperate climate, varied regional terrain for test drives and low altitude. (The area is only a few feet above sea level - a critical parameter when instrument testing emissions.) The new facility is capable of analyzing hundreds of vehicles, prototypes and customer-owned vehicles, annually.
Most interesting to us was the huge stainless steel climate chamber, with a massive four-wheel dynamometer that allows VW to test running vehicles in both scorching desert and freezing climates without ever leaving the building (an Audi Q7 was running in place during our visit). We were also mesmerized by the countless storage tanks and intricate plumbing of chemicals, stored in both liquid and gas states, needed to perform the variety of tests. Lastly, we took a look at Bugatti's service center on the west coast, located completely within the new center. While there were no supercars on site, the facility is equipped with plenty of spare forged wheels (mounted with expensive Michelin PAX tires) and a Veyron-specific repair jig that allows the vehicle to be completely disassembled, if needed. It is a shame that the facility, which set off all of our automotive geek alerts, is closed to the public.

ACEEE strips away VW's green car scores

The American Council for an Energy-Efficient Economy (ACEEE) is confirming that the Volkswagen diesel-emissions scandal has put a black mark on its green ratings. As a result, the group is pulling VW diesel vehicles off of its "Green Scores" list because it was recently revealed that VW diesels might be emitting as much as 40 times the nitrogen oxide (NOx) emissions during normal driving as the official test results show. The ACEEE added that other German makers of diesel vehicles' "Green Scores" are safe, for now. Diesels from VW and the company's Audi division didn't exacatly top the ACEEE's list of greenest vehicles for 2015. That honor went to electric vehicles like the Smart ForTwo ED, Chevrolet Spark EV and Fiat 500E. The Toyota Prius C hybrid snuck in at number 4, while the Nissan Leaf battery-electric took the fifth spot. That said, the VW diesels did perform pretty well, according to the group. "These scores are no longer reasonable estimations of the environmental impact of the Volkswagen diesels. Volkswagen's diesel cars have performed well on ACEEE's annual rankings since 2009, hovering just below our list of the top twelve "Greenest" vehicles with Green Scores in the high 40s," wrote Shruti Vaidyanathan, senior transportation researcher at the ACEEE. "However, a 40-fold increase in on-road NOx would mean that these vehicles did not deserve those high Green Scores." For those curious, the Ram 2500 pickup topped the ACEEE's "Meanest" vehicle of 2015, followed by the Chevrolet G2500 Express/GMC Savana. No diesels showed up on that list of environmentally-damaging vehicles. You can read the ACEEE's statement on VW below. Why we are suspending Volkswagen diesel Green Scores on greenercars.org by Shruti Vaidyanathan, Senior Transportation Researcher On September 18th, the Environmental Protection Agency (EPA) slapped the Volkswagen Group with a notice of violation (link is external) of the Clean Air Act for circumventing EPA emission standards for nitrogen oxides (NOx). Volkswagen has now acknowledged using so-called "defeat devices" on its diesel cars that turn on full emissions control technologies while in testing mode but allow the vehicles to emit nitrogen oxide levels up to 40 times the certified level during normal operation.

VW exec calls US ops a 'disaster'

Today in the Tell Us How You Really Feel file we have Bernd Osterloh, head of Volkswagen AG's Group Works Councils and member of the company's supervisory board, labeling the company's US operations "a disaster." Why? Because Osterloh believes VW of America doesn't have the models it needs to be competitive here, hasn't been decisive enough about its plans and German higher-ups still don't understand the US market.
In truth, the top labor rep at the German conglomerate is echoing sentiments we've heard from VWoA executives for years, and there's been the same commentary from dealers: Germany doesn't pay enough attention to what the US market really wants. Even ex-VWoA CEO Stefan Jacoby, who preceded the recently departed Jonathan Browning, said early in his tenure that one of his tasks was to get his German bosses to start delivering what the US market demanded. New CEO Michael Horn is saying much the same thing seven years later, telling Sky News that it has to increase "the speed at which we bring new models to the market and innovation to the market."
Osterloh wants to get "more models" here, including a pickup truck, but we'd wonder if the economics have changed from when Jacoby said they'd need to sell 100,000 per year to make money. Osterloh also wants a decision on where the CrossBlue will be built. Although it looked as if the Chatanooga, TN plant would get the call, the Puebla, Mexico plant is still in the running because of lower operating costs. No matter what happens right now, Osterloh thinks the situation won't get better for another two years when revamped models arrive, but at least the company can start taking the steps for a better US future.