2005 Toyota Rav4 L 4x4 / Awd / 4wd on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Lexus takes aim at electric vehicles, again

Lexus is once again taking aim at plug-in vehicles by emphasizing the perceived challenges of recharging batteries, rather than simply filling up with gas or hydrogen. Only this time, Toyota's luxury division appears to be zigging while everyone else is zagging. Of course, the nameplate can use all the help it can get when it comes to hybrid sales. First highlighted by Green Car Reports, Lexus has added a banner to the website of its hybrid vehicles that says "Always Charged. Always Ready." That's a not-so-veiled shot at plug-in vehicles, a sector where Toyota has minimal exposure. Lexus also notes of its hybrid vehicles that there's "nothing to plug in." Of course, there may be sour grapes at play. Through September, sales of its five hybrid models in the US dropped 17 percent from a year earlier to about 21,500 units, and September was particularly tough as hybrid sales plunged 34 percent to almost 1,800 units. Even so, the third quarter likely represented a record when it came to plug-in vehicle sales. We say "likely" because Tesla doesn't break out its US sales, and not all automakers disclose sales of their plug-ins. We calculate that sales for the quarter were at about 36,000 vehicles, up 38 percent from a year earlier. For now, Lexus doesn't sell a fuel-cell model, though it may sell a fuel-cell version of the Lexus LS full-size sedan. Toyota, of course, offers the Mirai, which has moved about 710 units this year. Lexus has gone down this proverbial road before. In 2014, the brand unveiled a similar campaign that highlighted how long it took to recharge EVs, and was ultimately taken to task by electric-vehicle advocates Plug-In America. Lexus apologized for offending anyone and said it'd review content related to hybrid advertising. Doesn't seem like an apology is in order this time out, but that doesn't mean that it's a good strategy. Related Video: Featured Gallery 2018 Lexus LC 500h View 40 Photos News Source: Green Car Reports Green Marketing/Advertising Recalls Lexus Toyota Hybrid

Toyota confirms 2016 Tacoma for Detroit

A week on from an announcement by Toyota's Bob Carter, the Japanese marque has formally announced that the 2016 Toyota Tacoma will make its global debut next month at the 2015 North American International Auto Show. Not only that, but the company has given us a very minute (and very muddy) teaser image, showing the truck's tailgate and driver's side taillight. Like its big brother, the Tundra, the 2016 Tacoma will feature its name embossed on its tailgate. Beyond that, though, there's really not much to be gleaned from this sole teaser shot. Of course, we'll have much, much more on the next-generation Taco when it arrives in a month's time. Until then, check out Toyota's hilariously brief and to-the-point press release, available below. Tacoma. Detroit. January 12. It's on. December 10, 2014 Toyota's rolling out the all-new 2016 Tacoma at the 2015 North American International Auto Show in Detroit on Jan. 12.