2012 Toyota Prius Iii With Factory Appearance Package, Rims, Leather, Nav on 2040-cars

Auto blog

Toyota and Lexus recalling 235,000 hybrid CUVs and sedans over separate issues

When it rains, it pours. Toyota has announced a pair of separate but voluntary North America recalls covering approximately 235,000 vehicles built between 2006 and 2011. The larger of the two recalls targets Toyota's hybridized crossovers, the Lexus RX400h and Toyota Highlander Hybrid. 133,000 units, including 2006-2010 Highlander and 2006-2008 RX crossovers are covered in the campaign. The other recall affects 102,000 IS350 sedans, IS350C convertibles and GS350 sedans built between 2006 and 2011.
With the CUVs, the faults in the parallel circuits of the transistors can cause heat damage in the inverter assembly, triggering an abundance of warning lamps and sending the vehicle into limp mode. The Lexus sedans are being recalled due to loose bolts on the variable valve timing controller. Detected by unusual underhood sounds on startup, the issue can cause the engine to stop while driving. The inverter issue is also triggering similar recalls in Japan and Europe.
At the moment, it's unclear if any of these issues have caused any crashes or injuries. Toyota says it plans to notify owners of the recall via snail mail. Additional information for owners can be found on the recall sites for Toyota and Lexus or by calling Toyota's customer service line, at 1-800-331-4331. Scroll down for the complete recall notice from Toyota.

Recharge Wrap-up: Minnesota first to require biodiesel, maglev in Israel, Toyota FCV in Aspen

A new Minnesota law that requires biodiesel blends goes into effect in just a few days, says KELO. Diesel drivers in Minnesota will be pumping soybeans into their tank beginning July 1. Every year, diesel will be sold as a B10 blend (ten percent biofuel) from April through August, and will scale back to a cold-hardy B5 blend from September through March. The biofuel largely comes from soybean crops grown within Minnesota, and the biodiesel industry pumps more than $900 million into the state economy every year. According to the National Biodiesel Board, using the B10 and B5 blends will reduce greenhouse gas emissions by 1,342,000,000 pounds every year. Minnesota is the first state to require diesel to be sold as a biofuel blend. In Japan, Isuzu Motors and Japanese biotech venture Euglena are teaming up to create biodiesel using algae, according to Bloomberg Businessweek. The goal is to create a new type of fuel that doesn't need to be mixed with light oil to be used in engines. "As long as we use light oil for diesel engines, emissions of carbon dioxide are inevitable," says Isuzu president Susumu Hosoi. Euglena has also been using algae to develop jet fuel with airline operator ANA Holdings. Isuzu and Euglena hope to have the new biodiesel developed by 2018. Aerial maglev transportation is coming to the campus of a defense contractor in Tel Aviv, Israel, Wired reports. The SkyTran personal rapid transit system uses small pods on an elevated magnetic track to move people from place to place. The pilot program will see SkyTran come to the corporate campus of Israel Aerospace Industries as soon as next year. The pods are hailed by phone, and carry passengers along the magnetic rail system at speeds of up to 44 miles per hour. The passive magnetic system levitates the pod attachment a centimeter above the rails, while a burst of electricity propels the pod forward. If the test at the campus goes well, SkyTran could spread to Tel Aviv at large, moving up to 12,000 people per track per hour with top speeds of 150 mph. The pre-production prototype of the Toyota FCV will make its North American debut at the 2014 Aspen Ideas Festival on Friday, June 27. The hydrogen car's finished exterior was revealed in Japan on Wednesday along with its nearly $70,000 price tag. It will go on sale in Japan by April of next year, and will come to Europe and California in the summer of 2015.

West Coast labor dispute hampers Japanese automakers' US plants

The ongoing labor dispute between the International Longshore and Warehouse Union and port owners along the West Coast is starting to affect more Japanese automakers building vehicles in the US. The issue already forced Honda and Subaru to take the expensive option of airlifting some parts into the US weeks ago, and according to USA Today, Toyota and Nissan have begun doing so, as well. The choice hasn't been cheap, though, and Subaru's chief financial officer estimated that the decision cost around $60 million more per month than sending components by cargo ship. The effects continue to radiate, according to USA Today, and shortages of some models are possible. Honda is slowing production at its factories in Ohio, Indiana and Canada because the automaker doesn't have enough transmissions and electronics for some vehicles. Toyota already cut back on overtime at some factories. Nissan has only seen a small effect from the issue, though, because of its local suppliers. Dock workers and port owners have been negotiating on a new contract since last year, and the union has organized work slowdowns in response. According to USA Today, the automakers could move shipments to Canada or Mexico, but it would take longer for parts to arrive. News Source: USA TodayImage Credit: Mark Ralston / AFP / Getty Images Earnings/Financials Plants/Manufacturing UAW/Unions Honda Nissan Subaru Toyota shipping port labor dispute