2014 Toyota Prius C Three on 2040-cars

Auto blog

Unifor may establish local union for Toyota's Canadian plants

Union tactics apparently translate across borders, as Canada's Unifor may take inspiration from the United Auto Workers' recent move at the Volkswagen factory in Chattanooga, TN, and establish a local for the Toyota factories in Cambridge and Woodstock.
Unifor last attempted to organize the workers at the two factories, which are responsible for production of the Toyota Corolla (above), RAV4 and Lexus RX back in April, but that vote was eventually delayed. According to that report, 3,000 of the two plants' 7,500 employees signed union cards, but that apparently wasn't enough for Unifor to force a vote.
Because of this, the union is looking at the local approach, like what the UAW is attempting with VW.

Toyota Recalling 1.67 Million Vehicles Worldwide

UPDATE: Toyota is now announcing specifically which models are covered under its fuel pipe recall in the US. The company is repairing about 423,000 Lexus models that include the 2007-2010 LS, 2006-2011 GS, 2006-2011 IS, 2010 IS C and 2008-2010 IS-F. The automaker says that it isn't aware of any fires, crashes, injuries or fatalities caused by this problem. According to Toyota, the recall is because it's possible for the fuel delivery pipes and the fuel pressure sensor to form a bad seal with the gasket between them because of a protective coating protecting against corrosion on the pipes. It's possible for this to eventually cause a fuel leak, and obviously in a hot engine bay that's a potential fire risk. To fix the problem, dealers will replace the gasket and repair the gasket seating surface between the fuel delivery pipe and the fuel pressure sensor. The company will begin notifying owners soon. You can find the official press release, below. Toyota is issuing three separate recalls covering 1.67 million vehicles worldwide with most of those models in Japan. It looks like the campaigns' impact on the US may be smaller, though. According to Reuters, Toyota isn't aware of any accidents, injuries or fatalities affecting the models. Some yet-unnamed Lexus models might also be affected. The largest of the campaigns does not currently affect any US-market vehicles. About 802,000 units of the Toyota Crown Majesta, Crown, Noah and Voxy in Japan are being repaired to replace a seal that could leak in the brake master cylinder. Those already leaking get a new brake booster, as well, according to Reuters. The only recall currently believed to affect the US is due to a problem covering approximately 759,000 vehicles with 423,000 of them here. The repair is to fix a faulty fuel delivery pipe that could cause a fire if the fuel leaks out. Unfortunately, we don't know which models it covers. Autoblog spoke to Toyota spokesperson Mona Richard and was told the information was still "under embargo." When exactly that embargo will lift isn't yet known, but we're on the case. Finally, Toyota is recalling 190,000 Corolla Rumion and Auris models in Japan for a faulty evaporative emission control unit. Autoblog is in contact with Toyota, and we'll update this story as soon as we know more about its affect on the US market.

Ford F-150 could be affected by tornado-damaged supplier in S.C.

The disruption caused by a tornado that severely damaged a South Carolina auto-parts plant and killed a contract security guard last week could be felt by more automakers than just Ford and affect more than just its best-selling F-Series pickup, which is due for an update. And there’s still no estimate for when operations might resume at the plant. The Detroit Free Press reports that the BorgWarner plant in Seneca, near Greenville, makes transfer cases for F-150 and Super Duty pickups, the Ford Explorer and Expedition, Transit cargo vans, and Lincoln Navigator and Aviator SUVs. ItÂ’s also a supplier for the Ram 1500 and Toyota Tundra trucks. Transfer cases shift power from the transmission to the front and rear axles in four-wheel-drive vehicles. BorgWarner says it still has no update for when it might partially or fully resume operations. The tornado that ripped through the area in the western part of the state on April 13 tore the roof, walls and signage off the factory and killed a 77-year-old contract worker when the security building he was sheltering in collapsed. Only four or five others were inside the plant, which has been idled because of the coronavirus outbreak, when the tornado struck. In an SEC filing on Friday, Ford said it has sent employees to the site to help BorgWarner and assess the damage to FordÂ’s tooling. “Initial assessments indicate that the Ford tooling was not materially damaged in this incident,” Ford said in the filing. “We do not have sufficient information to estimate when the facility will be back on-line or whether or the extent to which this incident will impact our plans to resume production of four-wheel drive and all-wheel drive vehicles.” A Fiat Chrysler spokeswoman also told the Freep the company was working with BorgWarner on recovery plans. A Toyota spokesman told Autoblog that "we are collaborating with BorgWarner to help restore production for transfer cases for Tundra assembly. We are confident that theyÂ’ll fully recover over time." Like other automakers, Ford shut down production at its U.S. plants last month as a precaution against the coronavirus pandemic. But Ford hasnÂ’t yet said when it plans to reopen its factories. FCA is targeting May 4 to resume production. Models like the F-150 and Lincoln Navigator are major sources of profit for Ford, which estimated it lost $2 billion in the first quarter.