2010 Toyota Camry / Le / Automatic / Alloys on 2040-cars

Auto blog

US expands probe into ZF-TRW airbag failure-to-deploy to 12.3 million vehicles

DETROIT — U.S. auto safety regulators have expanded an investigation into malfunctioning airbag controls to include 12.3 million vehicles because the bags may not inflate in a crash. The problem could be responsible for as many as eight deaths. Vehicles made by Toyota, Honda, Kia, Hyundai, Mitsubishi and Fiat Chrysler from the 2010 through 2019 model years are included in the probe, which was revealed Tuesday in documents posted by the National Highway Traffic Safety Administration. It involves airbag control units made by ZF-TRW that were installed in the vehicles. The control units can fail in a crash, possibly because of unwanted electrical signals produced by the crash itself that can disable an air bag control circuit housed in the passenger compartment, according to NHTSA documents. The electrical signals can damage the control circuit, the documents say. ZF, a German auto parts maker which acquired TRW Automotive in 2015, said in a statement that it's committed to safety and is cooperating with NHTSA and automakers in the investigation. The case is another in a long list of problems with auto industry airbags, including faulty and potentially deadly Takata airbag inflators. At least 24 people have been killed worldwide and more than 200 injured by the inflators, which can explode with too much force and hurl dangerous shrapnel into the passenger cabin. The inflators touched off the largest series of automotive recalls in U.S. history involving with as many as 70 million inflators to be recalled by the end of next year. About 100 million inflators are to be recalled worldwide. On April 19, NHTSA upgraded the ZF-TRW probe from a preliminary evaluation to an engineering analysis, which is a step closer toward seeking recalls. So far, only Hyundai and Kia and Fiat Chrysler have issued recalls in the case. Four deaths that may have been caused by the problem were reported in Hyundai-Kia vehicles and three in Fiat Chrysler automobiles. NHTSA opened an investigation in March of 2017 involving the TRW parts in Hyundais and Kias. The upgrade came after investigators found two recent serious crashes involving 2018 and 2019 Toyota Corollas in which the airbags did not inflate. One person was killed. Jason Levine, executive director of the Center for Auto Safety, a nonprofit consumer group, said the ZF-TRW case shows the auto industry thus far has learned very little from Takata.

Toyota recalling 615k Sienna models over rollaway risk

Toyota has announced a recall affecting approximately 615,000 Sienna minivans due to a possible rollaway risk. All of the vehicles in question are from the 2004, 2005, 2007, 2008 and 2009 model years.
In an official statement, the automaker states that the problem stems from the vehicle's shift lever assembly. "Because of the potential for damage to the shift lock solenoid installed in involved vehicles, there is a possibility that the shift lever could be moved out of the 'P' position without the driver depressing the brake pedal," Toyota said. Because of this fault, the affected Sienna models could roll away without warning, increasing the risk for a crash.
Owners will be notified via first class mail, and the affected Sienna models can be taken to Toyota dealerships to have the shift lock solenoid replaced with a new one. Have a look below for the automaker's official release.

Toyota, Honda, Nissan and more collaborating to increase fuel efficiency

Toyota, Honda, Mazda, Nissan, Subaru, Mitsubishi, Suzuki and Daihatsu have announced an alliance that will see a push to improve fuel economy from both gas-powered and diesel-powered engines by as much as 30 percent before the end of the decade.
The newly assembled Research Association of Automotive Internal Combustion Engines put the roughly $20-million project together, with the Japanese government committing to half the cost while the eight manufacturers will chip in the rest.
According to Automotive News, the automakers will team up and share basic research on internal-combustion engines in a bid to cut costs. Eventually, the results of the research will find its way into a production vehicle, although it's unclear just when we'll see the fruits of this partnership on the road.