1993toyota 4x4 4 Runner on 2040-cars

Auto blog

Toyota twin-turbo V8 patent unearthed

An unremarkable patent focusing on a minor engine part has revealed that Toyota is at least considering a twin-turbo V8. While the filing is most likely just a large company protecting its intellectual property, it could also be a small glimmer of hope that Toyota, a storied company that's made some glaring missteps with enthusiasts in recent years, can leave the ICE party with a bang for the ages. The patent for a secondary PCV separator, whose function is to isolate exhaust gas from lubricating oil, was discovered by a member of the GR86 forum. In this case, it's not engine oil that's the culprit, but turbocharger oil. From a twin-turbo V8. The patent starts out with an almost embarrassingly hilarious stick figure drawing of a car and where said engine would be located (in the front, under the hood, duh). It has the words "Internal Combustion Engine" printed on a rectangle in case there was any doubt. However, the second figure shows a dual turbo setup nestled in the valley of a V8. It's a prime location for reducing turbo lag and optimizing throttle response (and should necessitate a substantial hood bulge as well). Now, interestingly, the forum member believes this engine will be installed in the next Tundra (and presumably Sequoia), but our own research indicates that the pickup will have a 3.5-liter twin-turbo V6 under the hood. With all due respect to the GR86 members, we're going to stand by that assertion and cross our fingers that the patent hints at something even better. That would be a high-performance Lexus, possibly an IS F or, if the ICE gods will allow it, an LC F. After all, we have had reports from Japan that a trio of F-cars were coming, including a LS F. It would explain why the 472-horsepower, V8-powered IS 500 was called the Sport Performance instead of full-on IS F. In fact, Lexus reps have promised that the F label would become even more performance oriented. A proper IS F would be a fitting sendoff to Toyota's high-performance V8, but the tested, then reportedly canceled, then reportedly revived LC F would be an even more melodious swan song. The flagship grand tourer could very well allow loyalists to forgive the aforementioned gaffes. Toyota president and noted car guy Akio Toyoda has taken heat for questioning the coming outright ban of ICE sales in his home country of Japan. Perhaps this engine is one of the reasons he's objecting.

177k Toyota Camry Hybrids being recalled for brake issue

It looks like Consumer Reports might be getting part of what it wants regarding the Toyota Camry Hybrid and its braking system. Toyota is issuing what it calls a limited service campaign, rather than a full recall, covering about 177,500 of the hybrid sedans from the 2007 through 2011 model years because of an issue with the cars' brake fluid reservoirs.
The models have a filter separating two chambers of the brake fluid reservoir, and the part can get clogged over time. If this happens, the fluid level in one of the chambers can get too low and eventually cause the power assist to fail. There are multiple warning lights on the dashboard that illuminate over time if the filter gets obstructed, though. The company is replacing the entire reservoir with an improved unit, and the fix takes about two hours to perform.
Consumer Reports recently began asking for a recall on these models for the potentially clogged filters. The magazine also reported a second issue with the ABS brake actuator that could lead to a difficult to depress brake, but Toyota has increased the warranty on the part to 10 years or 150,000 miles.

Toyota, Mazda $1.6 billion plant goes to Alabama, sources say

Alabama will be the site of a new $1.6 billion Toyota and Mazda auto plant, a victory for President Donald Trump who had prodded manufacturers to build new U.S. facilities and threatened tariffs on foreign production, sources said on Tuesday. The plant, which will employ up to 4,000 people and produce about 300,000 vehicles a year, will be located in Huntsville, Ala., and is a boon for the state, where Toyota has a large engine plant and an existing network of automotive suppliers. A formal announcement by company and state officials is expected on Wednesday in Montgomery, sources briefed on the matter said. The new plant — in a state Trump won by 28 points in 2016 — could be a political boost to the Republican president, who has urged automakers to build plants in the United States and add jobs. The companies said they expect the plant to open in 2021. Trump tweeted in March he wanted "new plants to be built here for cars sold here." The White House did not immediately comment on Tuesday. The announcement also comes at a time of declining U.S. auto industry sales, so it could exacerbate overcapacity and add pressure to cut prices. U.S. new vehicle sales fell 2 percent in 2017, after hitting an all-time record high in 2016, and are expected to fall further in 2018. Details of an anticipated tax and incentive package for the investment were not yet known. It has been reported the companies sought at least $1 billion in incentives. A Toyota spokesman declined to comment, except to say an announcement was expected soon. A Mazda spokeswoman also declined to comment. In recent months, the companies had narrowed their choices down to sites in Alabama and North Carolina. Local media last month said the leading site under consideration was in northern Alabama's Limestone County, near Toyota's large engine plant in Huntsville. In September, Toyota announced a $106 million technology upgrade for the Huntsville plant. A Chamber of Commerce of Huntsville website for the "Huntsville Mega Site" touts the fact it has been "certified as development-ready." The commerce chamber, local and state officials declined to comment on Tuesday on plans for the plant. A year ago, President-elect Trump criticized Toyota and threatened hefty tariffs against the Japanese automaker if it built its Corolla sedan for the U.S. market in Mexico. "Toyota Motor said will build a new plant in Baja, Mexico, to build Corolla cars for U.S. NO WAY! Build plant in U.S.