2008 Subaru Outback, One Owner, No Sccidents, Looks And Runs Fine. on 2040-cars

Auto blog

Subaru investigation confirms vehicle data tampering in Japan

Subaru has admitted that alteration of fuel-economy and emissions data took place in its Gunma and Yajima manufacturing plants between December 2012 and November 2017. Some 900 vehicles were affected by data tampering, which Subaru says was done in the vehicles' final inspections by factory-floor inspectors. In a report, Subaru says "non-conforming" final vehicle inspections were identified in late 2017, and that the Japanese Ministry of Land, Infrastructure, Transport and Tourism demanded that Subaru undertake an internal investigation of the matter. Almost 7,000 vehicles were subject to inspection in the investigated time period, and the measurement equipment retained test data for some 6,500 of those. It showed that 903 vehicles had had their data "inappropriately altered," partially so that average data values would meet quality control standards. Subaru says that the decision to do this was made among vehicle inspectors and their foremen. As Subaru's statement reads: "Inspectors engaging in sampling of fuel economy and emissions were instructed by their seniors that, if results for each vehicle did not meet such standards, measurement values should be altered to those that meet such standards, and, according to such instructions, the inspectors altered measurement values. [...] Even if there were no problems in comparison with the internal quality control standards, inspectors altered measurement values with the intention of reducing variance in measurement values in order to avoid questions from the Group Chiefs and the Section Chief on such variance. It should be noted that alterations were made not only to make results better, but also to make them worse." It appears that everything was done to keep the average values right. Subaru adds: "Although the relevant laws and regulations stipulate that, in certain limited cases, measurement values could be altered in order to adjust errors caused by measurement equipment, inspectors misunderstand such adjustment method because of deficient internal rules and inadequate training. Inspectors altered measurement values by adjustment methods not stipulated in the relevant laws and regulations, without understanding that their methods were inappropriate." Test equipment did not contain data from earlier than 2012, but Subaru suspects such tampering took place as long ago as 2002. However, the matter will not result in recalls.

2015-18 Subaru Foresters recalled because front airbag may not deploy

Subaru is recalling 366,282 Foresters from model years 2015-18 because the front passenger airbag may not go off when it should during a crash. The problem stems from Subaru’s “Occupant Detection System,” which may not be able to detect a person sitting in the seat due to a loose connection. ThereÂ’s an electrical connection under the passenger seat that may loosen over time, according to Subaru. That connection is necessary for the detection system to function. Subaru says that only cars equipped with heated front seats are subject to this recall, as those are the only ones equipped with the specific harness where this would be possible. If your Forester is experiencing this problem, Subaru says you may see the “airbag warning” light illuminate on your dash. The “Passenger airbag off” indicator will also be illuminated, so that makes two different lights to check to see if your airbag is working. In turn, the seat wonÂ’t recognize the presence of a person in the front passenger seat, and the airbag may not deploy in a crash. Subaru will inspect the vehicles it recalls and replace the sensor mat harness if necessary. If you own a 2015-2018 Forester with heated front seats, look out for a note in the mail informing you of a recall. YouÂ’ll need to take the car in to the dealer, where the recall work will be done free of charge. As of now, Subaru isnÂ’t aware of any injuries or fatalities associated with this problem.

Subaru recalling 32K Imprezas for potential airbag fault

Following a preliminary evaluation by the National Highway Traffic Safety Administration in April 2015, Subaru is recalling 32,400 examples of the 2012 Impreza sedan and hatchback to repair the Occupant Detection System. The affected vehicles have production dates between April 21, 2011, and February 16, 2012. However, the WRX and STI are excluded from this campaign because they use a different part. The Impreza's problem concerns the front passenger seat's Occupant Detection System. In these models, the part uses capacitance to determine if someone is present and activates the airbag. According to the documents submitted to NHTSA (as a PDF), if the person sitting there uses a device plugged into the accessory outlet or touches an electrically grounded part like the metal seat adjuster, the ODS recognizes an increase in capacitance. It can then deactivate the airbag. Obviously, this could be a hazard in a crash, but there would be a warning light showing the safety device as off. To solve the problem, dealers will install a modified Occupant Control Unit. The initial investigation was prompted after 26 complaints to NHTSA about the ODS not working properly. In 2012, Subaru also issued a technical service bulletin that attempted to repair the issue. Related Video: RECALL Subject : Front Passenger Air Bag may not Deploy Report Receipt Date: JUL 01, 2015 NHTSA Campaign Number: 15V419000 Component(s): AIR BAGS Potential Number of Units Affected: 32,400 All Products Associated with this Recall Vehicle Make Model Model Year(s) SUBARU IMPREZA 2012 Details Manufacturer: Subaru of America, Inc. SUMMARY: Subaru of America, Inc. (Subaru) is recalling certain 2012 model year Subaru Impreza 4-Door and Station Wagon vehicles (except WRX/STI models) manufactured April 21, 2011, to February 16, 2012. In the affected vehicles, the Occupant Detection System (ODS) may deactivate if a front seat passenger operates a device that is plugged into the power outlet such as a music player or cell phone, or touches a metal part of the vehicle such as the forward/rearward seat adjuster lever. CONSEQUENCE: If the ODS deactivates, the front passenger air bag will be turned off and the front passenger air bag will not deploy in the event of a crash, increasing the risk of injury to the seat occupant. REMEDY: Subaru will notify owners, and dealers will replace the Occupant Control Unit with a modified one, free of charge. The manufacturer has not yet provided a notification schedule.