2022 Subaru Ascent Onyx Edition on 2040-cars

Auto blog

Subaru profits fall by half last year among recall maladies

Subaru took a financial beating last year, according to its freshly released earnings report. During the full fiscal year, which ended March 31, the carmaker's operating profits effectively halved. Net income dropped 33% to 147.81 billion yen, or $1.33 billion, and revenue fell 2.2% to 3.16 trillion yen ($28.5 billion). Subaru states that its operating income declined by 48.5% to 195.5 billion yen, or to about $1.78 billion. According to Subaru, this was not only due to a decrease in sales, but also due to recall campaigns. Total production decreased nearly 6% to 989,000 units, and production stoppages at the Gunma plant were partially to blame for that — but Impreza, XV and Levorg sales also sank. The redesigned Forester did start out well in the summer, but sales in the first half of 2018 were more modest with the outgoing generation still in the showrooms. The Gunma manufacturing plant, Subaru's sole factory in Japan, ground to a halt in January 2019 to remedy issues with Forester, Crosstrek and Impreza electric power steering units, and that cost Subaru nearly 10 days of production, corresponding to around 30,000 vehicles. Earlier, there was a 500,000-vehicle recall in Japan due to fraudulent final inspections. Automotive News also lists other recent Subaru maladies, such as a low-fuel warning recall and stop-sale for all U.S-market Outbacks and Legacys, and the earlier, global recall to repair valve springs on the boxer engines of 411,000 vehicles. This particular recall hasn't been problem-free, as there have been cases where subsequent engine failures on BRZ models have been suspected of having been caused by slapdash recall work. There is also a new, large-scale recall in the horizon for Subaru, as a brake light issue on 2008-2017 vehicles necessitates the recall of some 2.3 million vehicles. However, it's not all bleak for Subaru, as U.S. sales are going strong. The carmaker predicts 2019 will be the 11th straight record year, and U.S. retail sales climbed 7.7 percent in April, which was the 89th consecutive month with increased sales. But still, not all Subaru markets are equal: On the North American market, Subaru sold 717,000 vehicles during the past fiscal year, an enormous percentage of its total sales. News Source: Subaru via Automotive News Plants/Manufacturing Recalls Subaru

2019 Subaru Forester: Refined by evolution

Here it is, the all-new 2019 Subaru Forester, a lot like it was before, and a lot different. Spy shots clued us in to evolutionary exterior on this fifth generation, which Subaru dubs "a more rugged style." Taking cues from the Ascent, instead of bodysides decorated with a couple of character lines, Subaru designers stressed the sculpture of the entire span. In front, A larger, black gloss-finish grille cuts deeper into the bumper from the top. The headlight housings carry over in shape, but now hold LED lamps standard on all trims. Along the sides, punched-out wheel arches frame an angled shoulder that cuts into the C-pillar and wraps around the side glass. Design tweaks and the move to Subaru's Global Platform bring a 1.2-inch longer wheelbase and 1.4 more inches of rear legroom. Occupants up front sit in new, more comfortable seats and enjoy more space in the center tunnel thanks to an electronic parking brake. In back, wider rear door openings and a steeper C-pillar allow easier ingress. The tailgate opening increases by 5.3 inches in width, onto a squarer cargo area with a flatter floor and a standard cargo tray. An interior LED illuminates the load bay when the tailgate's open, an exterior floodlight shines outside the rear of the crossover. Lower the rear seats and access 76.1 cubic feet of loading room, 1.9 cu. ft. more than before. The carmaker says you can put golf bags in the car sideways without needing to tilt them, an arcane, yet commendable, achievement. A trim shakeup adds a new variant, the lineup being Base, Premium, Limited, Touring, and a new Sport model. Base and Premium ride on 17-inch wheels, the others get 18-inchers. All Foresters are powered by an "enhanced" version of the present 2.5-liter boxer four-cylinder with direct injection, higher compression, and active exhaust valve control. The engine now makes 182 horsepower, a 12-hp improvement, and 176 pound-feet of torque, a 2-lb-ft improvement. For you Forester experts, that means yes, the 250-hp, 2.0-liter turbocharged engine vacates the premises. Every trim gets a Lineartronic CVT and stop/start. Touring and Sport models get a manual mode and paddle shifters, mimicking a seven-speed gearbox. The Subaru Intelligent Drive (SI-DRIVE) offers Intelligent and Sport drive modes (Sport Sharp on the Sport trim); Intelligent prioritizes fuel economy, Sport maximizes thrills. Fuel economy reaches as high as 33 miles per gallon on the highway, depending on trim.

Subaru suppliers rely on gray market labor

The Subaru Forester is currently the Japanese brand's bestselling model in the US. A new investigation by Reuters is making some scathing allegations about how the popular model is actually made, though. The piece claims that many of Subaru's suppliers in Ota, Japan, are using low-paid foreign workers and asylum seekers to produce components that go into the CUV. The report says that these laborers are coming from places like China and Bangladesh, and they allegedly receive a pittance compared to their Japanese counterparts. Many said that they get about $6.60 an hour, but employment brokers can take a large portion of that pay. At just four suppliers Reuters estimates there are 580 foreign workers, or about 30 percent of the total workforce. The situation has turned Ota into a cultural melting pot because of the significant population of immigrant labor. The problem stems in part from Japan's tiny labor market, and the country's odd asylum system that doesn't allow some applicants to work legally. These suppliers produce many components for the Forester, including the seats, shocks, and fuel tanks. Reuters admits that the businesses have contracts with other Japanese automakers, as well, but Subaru receives the main focus of this piece, which you can read in full, here. When asked for comment about Reuters' report, Subaru of America provided Autoblog with the following statement: "Fuji Heavy Industries does not condone the exploitation of any class of worker, either in its own operations or within its supply chain. FHI expects all employees to be treated fairly, with dignity and respect and to be provided with appropriate workplace protections. The FHI CSR policy respects and adheres to the law and regulations of business as well as upholding human rights and international standards of behavior and the ethical standards of our stakeholders. Our supply chain network has been made aware of our policy and expectations."