2006 Saturn Ion Ion 2 4dr Sdn Auto on 2040-cars

Auto blog

GM recalling another 2.7 million vehicles in five separate campaigns

The recalls keep rolling in from General Motors, evidently keen to avoid repeating the mistakes of the ignition-switch debacle and clean house. This time they're all coming at once, with five separate recalls announced together covering approximately 2.7 million vehicles.
The largest of the five actions involves over 2.4 million units of the previous-generation Chevrolet Malibu and Malibu Maxx, Pontiac G6 and Saturn Aura in order to fix brake light wiring harness, which have been found to be susceptible to corrosion. The recall is separate from the 56k Aura sedans which GM recently recalled over faulty shift cables, not to mention the previous massive recall of 1.3 million vehicles - some of them the same models - but appears to have resulted from the National Highway Traffic Safety Administration investigation that started with the G6 almost a year ago.
The second-largest campaign involves the 2014 Chevy Malibu, specifically those fitted with GM's 2.5-liter engine and stop/start system, approximately 140,000 examples of which has been found to have problematic brakes. The issue does not appear to be connected to the recall of 8k Malibu and Buick LaCrosse sedans (also involving brake woes) which we reported upon last week. Four crashes have been reported in such models, but GM admits it's not yet clear if the problem was a contributing factor in the accidents.

GM recalling 426,000 sedans over faulty transmission shift cable

General Motors is recalling some 426,240 sedans that may have a faulty transmission shift cable, according to a National Highway Traffic Safety Administration report this morning. The recall concerns a fault within four-speed automatic transmissions equipped on 2007-2010 Saturn Aura models, and 2008-2010 Chevrolet Malibu and Pontiac G6 models.
The report specifies that tabs on the transmission shift cable may fracture and separate. Such a fault could cause a discrepancy between the actual position of the transmission and the apparent position of the shift lever.
GM is currently working to notify owners of the vehicles in question, and dealers will check and replace shift cables free of charge. Scroll down to read the complete NHTSA report.

Saturn Vue ignition issue was discussed three times before recall, new documents reveal

Despite the tens of millions of recalled vehicles this year, it's somewhat rare that we get a glimpse into what goes into deciding when to conduct one of these safety campaigns. New documents published by General Motors and the National Highway Traffic Safety Administration are giving us an interesting opportunity to see how the sausage is made and show the number of meetings it takes to declare a recall.
In early August, GM added about another 269,000 vehicles to its 2014 recall tally in the US when it announced a slew of new safety campaigns. Among them was a fix for the 2002-2004 Saturn Vue that covered 202,155 of them in the US. The problem was that the key could be removed from the ignition even when it wasn't in the "OFF" position, and that had caused two crashes and one injury, according to the automaker.
Where we start to see behind the veil is in the defect notice freshly released by NHTSA. It shows that GM began investigating more widely for ignition switches in April, shortly after the company expanded its ignition switch recall to a variety of Saturn products, among others, according to Automotive News. The automaker found 152 reports in the 2002-2004 Vue of vehicles rolling away or the key being removed out of a total population of 215,243 units worldwide.